APAC-Alabama, Inc.

An employee pulled out a bucket of hot oil from under the fryer. The employee then stood on the table to clean the back wall. He stepped down into the bucket of hot oil, resulting in third-degree burns to his left leg.

An employee was performing maintenance under a kettle. When he removed a tri-clamp on a transfer line, the hot fat and broth material in the kettle poured out onto his arm. The employee was hospitalized with burns.

An employee was filtering a fryer with a fryer filter machine. After going around the corner and then returning to the fryers, the employee stepped into the filter machine. The hot oil burned the employee's right ankle, and the employee was hospitalized.

An employee was using a water hose to clean debris out of the outfeed of a log conditioning vat. Water began entering the vat from the adjoining vat through a void in the separation wall at the infeed of the vats. As the employee was exiting the vat he had been working in using the access opening at the outfeed, hot water exiting the access opening entered the top of his protective hip wader. It pooled at the bottom of the wader and burned his left foot and ankle.

An employee was scraping dried glue from the top lid of a hot glue pot. His left hand slipped and came into contact with the hot glue. He then suffered burns to his hands and fingers as he tried to remove the glue. He was hospitalized.

An employee was cleaning the cylinder on a 55-gallon barrel pump. While he was cleaning built-up material from under the baseplate, the piston started moving and caught his thumb against the seat. Three-quarters of an inch of the thumb was degloved; he was hospitalized, requiring surgery.

An employee was actively involved in the rigging process and was providing verbal directions to both the forklift operator and the spotter. The operation was temporarily halted after the pole section was raised approximately two to three feet out of the ground to adjust the rigging. The employee walked under the forks and gave direction to lower them. While doing so, the employee placed their right hand on top of the rigged pole for support and used their left hand to adjust the rigging components. The base of the mast came in contact with the employee s right hand, resulting in a laceration and amputation of the right index finger.

A FESCO employee was on top of a trailer assisting a forklift operator with placing equipment onto the semi-truck trailer. While on top of the trailer, the employee stepped backward and fell off the trailer to the ground, landing on his back. The employee was hospitalized for a fracture of their C5 vertebra.

An employee was walking through a parking lot after leaving a shop when he slipped on ice and fell to the ground, resulting in a fractured hip.

An employee was walking near a 2.5-foot-deep excavation that had recently been filled with hot water from a steam condensate line. The mud he was walking on gave way, causing him to fall into the water and sustain second-degree burns to his right foot and shin.

An employee was traveling down the maintenance aisle of a warehouse on a single-pallet front rider jack. The jack malfunctioned, causing the brakes to apply; the employee fell forward onto the concrete warehouse floor. The employee suffered an injury to the left leg and was hospitalized, requiring surgery.

An employee was operating a metal roller machine to roll a small piece of metal. The employee's right index finger became caught between the metal and the machine, and the fingertip was amputated.

An employee was shot in the leg with a pistol during an altercation with two people who had entered the store without permission.

An employee was directing a truck driver to a dump site when the truck's peanut trailer slipped off the kingpin. As the trailer fell, a ladder attached to it lacerated the employee's ear. The employee was hospitalized.

An employee was unloading a forklift from a trailer to the ground. The employee was climbing down the ladder of the trailer when their foot slipped through one of the rungs, causing them to fall backward onto the forklift forks. The employee was hospitalized for fractured ribs.