Contact with hot objects or substances · Thermal burns degree unspecified
At a glance
Federal OSHA recorded a severe workplace injury
at Boise Cascade Wood Products, LLC, 8007 Florida Georgia Hwy, HAVANA, FLORIDA 32333
on — Thermal burns degree unspecified, affecting the Foot (feet) and ankle(s).
Final narrative
An employee was using a water hose to clean debris out of the outfeed of a log conditioning vat. Water began entering the vat from the adjoining vat through a void in the separation wall at the infeed of the vats. As the employee was exiting the vat he had been working in using the access opening at the outfeed, hot water exiting the access opening entered the top of his protective hip wader. It pooled at the bottom of the wader and burned his left foot and ankle.
Hospitalized Foot (feet) and ankle(s) Water, liquids nonchemical
An employee pulled out a bucket of hot oil from under the fryer. The employee then stood on the table to clean the back wall. He stepped down into the bucket of hot oil, resulting in third-degree burns to his left leg.
An employee was performing maintenance under a kettle. When he removed a tri-clamp on a transfer line, the hot fat and broth material in the kettle poured out onto his arm. The employee was hospitalized with burns.
After completing a run with an oil distributor truck, an employee was working to return (suction) the hot oil to the tank of the truck. When the employee opened one of the valves, hot oil (approximately 385 degrees) sprayed their face, resulting in first-, second-, and third-degree burns.
An employee was filtering a fryer with a fryer filter machine. After going around the corner and then returning to the fryers, the employee stepped into the filter machine. The hot oil burned the employee's right ankle, and the employee was hospitalized.
An employee was scraping dried glue from the top lid of a hot glue pot. His left hand slipped and came into contact with the hot glue. He then suffered burns to his hands and fingers as he tried to remove the glue. He was hospitalized.
More severe injuries in this industry (NAICS 321211)
On August 31, 2025, an employee was pulling a belt around a pulley when their right ring finger was caught between the pulley and the belt for the underdraft fan. The finger was lacerated and the employee was hospitalized.
An employee was on a ladder, pruning a tree in the outside picnic area. The employee lost their balance and fell. The employee was hospitalized with a fracture to their lower left leg.
On May 8, 2025, an employee was dumping a trash hopper while operating a forklift. His left hand was caught in a pinch point on the bottom of the trash hopper, resulting in a partial amputation to the index fingertip.
An employee was cleaning an air station with a pressure washer when the water stream went through their boot and contacted their left foot, resulting in a 1.5 inch by 1 inch laceration to the top of the foot.
An employee was loading logs onto a feeder chain into the chipper when his left hand was crushed between the throat of the chipper and the core. Two fingers were injured and surgically amputated.
An employee was helping a coworker transport a tall palm tree with a mini skid steer. The employee was severely shocked by a high-voltage electrical wire above the ground.
An employee was retrieving a Christmas tree from a shelf using a ladder. He missed a step and fell to the concrete floor. He sustained injury to his head and wrist.
An employee was operating an agricultural tractor during sugarcane harvesting. The employee sustained a lumbar sprain due to vibration or motion from the tractor.
An employee was moving a 3-ton condensing unit, strapped down on a dolly, out of a garage. The strap broke, causing the employee to fall backward onto the brick pavered driveway. The employee suffered injury to a spinal ligament in the neck.