JBS USA, LLC

An employee was setting a piece of beef near the skinner machine when the blade amputated his right ring fingertip.

An employee was walking through the basement when they stepped in hot water and sustained second- and third-degree burns to the feet.

An employee was replacing film on equipment when their left middle finger contacted the film guide, resulting in an amputation just below the nail.

An employee was emptying a spinal vacuum tank. The employee's right middle finger was caught in a valve; the tip was amputated.

The injured employee was at the hand wash sink. Another employee went behind her and fell backwards lacerating the injured employee's upper left shoulder with a knife.

At 4:00 p.m. on July 3, 2023, a severe thunderstorm passed over a job site. An employee was taking shelter under a carport where batteries were stored. The carport was destroyed; flying objects struck the employee, who suffered a jaw injury and a knee injury.

An employee was struck in the head by a hockey puck while exiting the locker room. The employee sustained a laceration above their left eye.

An employee was clearing a clogged sugar chute, containing rare earth magnets inset into an aluminum bar to catch any metal in the sugar. The employee loosened the middle of three magnets and it was attracted to the outside magnet, crushing the tip of his right middle finger. The fingertip was amputated.

An employee was working in the pallet repair line when a pneumatic nail gun shot a nail into their right wrist. The employee was hospitalized and required surgery to remove the nail.

An employee was emptying a plastic bucket of soils around a newly planted tree using a hay hook to assist. The hay hook suddenly broke free of the plastic bucket and struck the employee in the right eye, resulting in blunt-force trauma injuries to their eye.

An employee was scraping dried glue from the top lid of a hot glue pot. His left hand slipped and came into contact with the hot glue. He then suffered burns to his hands and fingers as he tried to remove the glue. He was hospitalized.

An employee was in a scissor lift approximately 20 feet above the ground to place a plastic tarp on a catwalk in order to catch condensation. They positioned the lift opposite the work area and stepped out of the scissor lift onto an I-beam. The employee fell from the I-beam to the ground. The employee was hospitalized with a skull fracture on the right side of their head and injuries to the chest and both eyes.

A maintenance employee was called to look at a pallet conveyor machine where a chain had fallen off a sprocket wheel. When the employee grabbed the loose chain, a light sensor caused the machine to restart. This created a pinch point between the chain and sprocket that caught the employee's left little finger. The finger was surgically amputated at the second knuckle.

The injured employee was standing by one of the stationary computers along the wall. There was a half-pallet located approximately 3 feet behind the employee that consisted of 12-pound boxes stacked six boxes high. A forklift was transporting a pallet that came in contact with the stationary pallet behind the injured employee, causing four boxes to fall and contact their legs. The injured employee was hospitalized with leg injuries.

An employee was using a box strapping machine to place straps on boxes when his right middle finger was caught in the machine, resulting in an open fracture to the distal phalanx.

An employee was stacking concrete blocks for a concrete bunker. As a block was swinging into place, the employee's left leg was pinched between two blocks, resulting in injuries to his left heel and lower leg.

An employee was climbing a ladder to inspect a vent in a restaurant dining area. The ladder slid out on the floor and the employee fell approximately 12 feet onto the ladder and the floor. He was hospitalized with a dislocated shoulder and a back injury.

An employee was rappelling down a tree. When he was most of the way down, he fell on the ground and suffered a broken pelvis.

An employee was filtering a fryer with a fryer filter machine. After going around the corner and then returning to the fryers, the employee stepped into the filter machine. The hot oil burned the employee's right ankle, and the employee was hospitalized.

An employee was cleaning out corn from a grain bin. The sweep auger in the bin was activated and caught his trouser leg. His leg was pulled into the auger, which injured his calf and caused leg fractures and lacerations.