YORK, PENNSYLVANIA—
Exel, Inc.
Other fall to lower level less than 6 feet · Internal injuries to organs and blood vessels of the trunk
At a glance
Federal OSHA recorded a severe workplace injury at Exel, Inc. , 300 South Salem Church Road, YORK, PENNSYLVANIA 17408 on — Internal injuries to organs and blood vessels of the trunk, affecting the abdomen, except internal location of diseases or disorders.
Final narrative
On 10/22/2015 at approximately 10:10 pm, a forklift operator stopped his forklift and placed it in park. The employee took a drink of water that caused him to cough and presumably choke. The coughing, caused the employee to lose consciousness and fall from the forklift suffering eight broken ribs and a lacerated spleen.
More severe injuries at Exel, Inc.
LOCKBOURNE, OHIO—
Exel Inc.
An employee used an attached rope to pull a door down and close it, then placed his foot on the foot bar to lock it. The rope looped around his foot. When he began to walk away, he tripped and was swung around, causing his left foot to come out from beneath him. He fell onto his right hip and broke it. He was hospitalized, requiring surgery.
LOCKBOURNE, OHIO—
Exel Inc.
An employee was exiting a trailer after putting a label on a skid inside the trailer. The trailer began pulling away and the employee fell to the ground. The employee sustained fractures to their ribs on the right side, right kneecap, and a left toe.
COLUMBUS, OHIO—
Exel Inc.
The injured employee was sitting in a parked forklift while another forklift was moving two metal tire racks. The top rack was empty and the bottom rack contained tires. As the racks were being lowered to the ground, they fell and the top rack struck the injured employee. The employee was hospitalized with lacerations and a fracture to the left foot, and they required surgery.
SPRINGFIELD, MISSOURI—
Exel Inc.
An employee was driving a stand-up counterbalance forklift down an aisle in a warehouse. The forklift abruptly turned; the employee's leg moved and the dead man switch activated, throwing the employee out of the forklift. Their right leg was crushed between the material-handling equipment and a racking system, and it was amputated above the knee.
WESTERVILLE, OHIO—
Exel Inc.
An employee was attending a training course at the corporate office. At the end of the course, the group went outside to a patio to take a photo. The employee slipped off the patio stairs and fell to the grass-covered ground at the same level. He was hospitalized with a broken femur and broken hip.
View Exel, Inc. 's full OSHA safety record →
Similar incidents · Same event type
JACKSON, MISSOURI—
Electrical Contractors Inc.
An employee was climbing a step ladder while carrying a 3-foot piece of conduit. As he went to reposition his feet on the ladder by pivoting, he slipped and fell from the third rung of a 6-foot ladder. The employee sustained fractures to the left femur, right elbow, and right ring finger.
FORT RUCKER, ALABAMA—
M1 Support Services
An employee was descending a 4-step maintenance stand when she missed the bottom step and fell to the hangar floor. The employee suffered a left hip fracture.
PHILADELPHIA, PENNSYLVANIA—
FEDEX Ground Package System, Inc.
An employee stopped a belt and was going to check it for missing packages. She fell backward 3-4 feet from an elevated platform and sustained a broken right arm.
LAFAYETTE, COLORADO—
SRM Concrete
An employee had just finished a routine concrete pour and was ascending the ladder to clean the concrete mixer truck. The employee lost their grip and fell approximately 2-3 feet, contacting the truck's bumper. The employee suffered rib fractures and a punctured lung.
LOS ANGELES, CALIFORNIA—
U.S. Postal Service - Los Angeles P&DC
An employee was performing duties as an expeditor. After opening the dock door, the employee scanned the barcode on the door of the truck and placed one foot on the truck and one foot on the dock. The truck drove out of the stall, causing the employee to fall 4 feet off the dock onto the concrete. The employee sustained fractures to the right side of the pelvis, elbow, and a left ring fingertip as well as injuries to the right wrist and bruising to the back and stomach.
More severe injuries in this industry (NAICS 493110)
LIMA, OHIO—
GXO Logistics
On October 30, 2025, an employee was working to adjust a stackable metal shipping container. As the container dropped into place, it caught the employee's hands in an area between the upper and lower cross-members. The employee suffered a laceration to the left ring finger that required stitches, bruising to the right ring finger, and fractures to the right middle finger that necessitated medical amputation of the fingertip.
MCDONOUGH, GEORGIA—
PVH, Corp.
A temporary employee was punched in the face by another temporary employee. He suffered a laceration to the eye.
PRINCETON, ILLINOIS—
Ace Hardware International LLC
An employee was backing up a powered industrial vehicle. Her left hand was caught between the vehicle and a rack, and the wrist was broken.
ROCKWALL, TEXAS—
Agave Wire Ltd
An employee was operating an extruder and performing a spool swap over from the right spindle to the left spindle. After rewiring the new spool, the employee's clothing got caught in the turning shaft when the left spindle started back up. The employee's left arm was pulled into the machine, resulting in a fractured humerus and lacerations to her triceps. She was hospitalized and required surgery.
YORK, PENNSYLVANIA—
M&M Quality Solutions
An employee was resetting a warehouse racking system utilizing an order picker. They fell approximately 5 feet from the order picker to the concrete floor and sustained fractured ribs.
More severe injuries in PENNSYLVANIA
WYNNEWOOD, PENNSYLVANIA—
Main Line Clinical Labs
An employee was closing a door when the door closed on their right index finger, resulting in a fingertip amputation.
POCONO SUMMIT, PENNSYLVANIA—
Ardent Mills
An employee was walking into the motor control center (MCC) room when his right ring finger was caught in the hinge of a doorway. He sustained an open phalanx fracture, which resulted in a partial amputation above the first knuckle.
LANCASTER, PENNSYLVANIA—
Zimmerman & Herr
An employee was changing the spacing on a telehandler's forks. A fork slipped, and the employee's left index finger was caught between it and the mast. The fingertip was medically amputated at the first knuckle.
EBENSBURG, PENNSYLVANIA—
McAneny Brothers, Inc.
An employee was pulling down a broken skid with a forklift. When the employee backed up the forklift to get the forks out of the skid he pulled down, he contacted the forks of another parked forklift, fracturing both of his legs. He was hospitalized.
PITTSBURGH, PENNSYLVANIA—
Metz Culinary Management LLC
An employee was carrying cups back to the kitchen when her foot got caught on a cart and she fell face-first. During the fall, a piece of glass from a cup cut the inside of her mouth, severing an artery. She also sustained a laceration on her lower lip. The employee was hospitalized.