WESTERVILLE, OHIO—
Exel Inc.
Other fall to lower level less than 6 feet · Fractures
At a glance
Federal OSHA recorded a severe workplace injury at Exel Inc., 360 Westar Blvd, WESTERVILLE, OHIO 43082 on — Fractures , affecting the Hip(s) and leg(s) n.e.c..
Final narrative
An employee was attending a training course at the corporate office. At the end of the course, the group went outside to a patio to take a photo. The employee slipped off the patio stairs and fell to the grass-covered ground at the same level. He was hospitalized with a broken femur and broken hip.
More severe injuries at Exel Inc.
LOCKBOURNE, OHIO—
Exel Inc.
An employee used an attached rope to pull a door down and close it, then placed his foot on the foot bar to lock it. The rope looped around his foot. When he began to walk away, he tripped and was swung around, causing his left foot to come out from beneath him. He fell onto his right hip and broke it. He was hospitalized, requiring surgery.
LOCKBOURNE, OHIO—
Exel Inc.
An employee was exiting a trailer after putting a label on a skid inside the trailer. The trailer began pulling away and the employee fell to the ground. The employee sustained fractures to their ribs on the right side, right kneecap, and a left toe.
COLUMBUS, OHIO—
Exel Inc.
The injured employee was sitting in a parked forklift while another forklift was moving two metal tire racks. The top rack was empty and the bottom rack contained tires. As the racks were being lowered to the ground, they fell and the top rack struck the injured employee. The employee was hospitalized with lacerations and a fracture to the left foot, and they required surgery.
SPRINGFIELD, MISSOURI—
Exel Inc.
An employee was driving a stand-up counterbalance forklift down an aisle in a warehouse. The forklift abruptly turned; the employee's leg moved and the dead man switch activated, throwing the employee out of the forklift. Their right leg was crushed between the material-handling equipment and a racking system, and it was amputated above the knee.
NORTH AURORA, ILLINOIS—
Exel Inc.
An employee was driving a counterbalance forklift down an aisle when the forklift began veering toward a rack. Their right little finger was pinched between the side pillar of the forklift and the rack, resulting in a partial amputation to the finger.
View Exel Inc.'s full OSHA safety record →
Similar incidents · Same event type
CHICOPEE, MASSACHUSETTS—
A&S Services Group
An employee fell while exiting a trailer. The employee landed on their left side on the pavement, suffering multiple broken ribs on the left side. The employee was hospitalized.
PINEVILLE, LOUISIANA—
Kisatchie Midnight Express
A driver was exiting his vehicle outside the plant gate when his foot slipped on the top step of the truck. He fell to the ground, landed on his left hip and elbow. The employee was hospitalized with a fractured hip/femur.
LIVERPOOL, NEW YORK—
Lockheed Martin Mission Systems and Training
Two employees were removing a service lift platform from the back of a radar system. While handling the service lift platform, employee 2 was standing on the back of the radar and lost their footing, causing the service lift platform to shift and fall. The injured employee then fell from the top of the platform electronic subsystem (PES) to the floor, approximately 56 inches. The injured employee fractured his left elbow and left hip.
JBSA LACKLAND, TEXAS—
Allen Tharp LLC.
An employee fell from a loading dock to the ground 2-3 feet below. She suffered a compound fracture of the left hip and was hospitalized, requiring surgery.
NEW BRUNSWICK, NEW JERSEY—
Allied Waste Systems Inc
An employee assisted in cleaning material from a conveyor pit. After the pit was cleaned, the employee proceeded to replace metal safety plates to ensure other employees did not fall into the pit. While replacing one of the last plates, the employee mis-stepped and fell approximately 5 feet into the pit. The employee was hospitalized with back/side bruising, elbow bruising, bone bruises, and/or fractured ribs.
More severe injuries in this industry (NAICS 493110)
LIMA, OHIO—
GXO Logistics
On October 30, 2025, an employee was working to adjust a stackable metal shipping container. As the container dropped into place, it caught the employee's hands in an area between the upper and lower cross-members. The employee suffered a laceration to the left ring finger that required stitches, bruising to the right ring finger, and fractures to the right middle finger that necessitated medical amputation of the fingertip.
MCDONOUGH, GEORGIA—
PVH, Corp.
A temporary employee was punched in the face by another temporary employee. He suffered a laceration to the eye.
PRINCETON, ILLINOIS—
Ace Hardware International LLC
An employee was backing up a powered industrial vehicle. Her left hand was caught between the vehicle and a rack, and the wrist was broken.
ROCKWALL, TEXAS—
Agave Wire Ltd
An employee was operating an extruder and performing a spool swap over from the right spindle to the left spindle. After rewiring the new spool, the employee's clothing got caught in the turning shaft when the left spindle started back up. The employee's left arm was pulled into the machine, resulting in a fractured humerus and lacerations to her triceps. She was hospitalized and required surgery.
YORK, PENNSYLVANIA—
M&M Quality Solutions
An employee was resetting a warehouse racking system utilizing an order picker. They fell approximately 5 feet from the order picker to the concrete floor and sustained fractured ribs.
More severe injuries in OHIO
DAYTON, OHIO—
United States Postal Service
An employee was working to deliver mail to an apartment building. She was waiting for a customer to move, to obtain clearance to the mailboxes. The door swung inward and closed on her right little finger. The top half of her finger was surgically amputated.
COLUMBUS, OHIO—
Foundation Steel, LLC
An employee fell from a step ladder while reaching for a tie-off point. He impacted the ground, and landed on his bolt bag which contained tools. The employee was hospitalized with fractured ribs, and a lacerated spleen and kidney.
LIMA, OHIO—
GXO Logistics
On October 30, 2025, an employee was working to adjust a stackable metal shipping container. As the container dropped into place, it caught the employee's hands in an area between the upper and lower cross-members. The employee suffered a laceration to the left ring finger that required stitches, bruising to the right ring finger, and fractures to the right middle finger that necessitated medical amputation of the fingertip.
CANTON, OHIO—
Abbott Electric Inc
An employee was moving a scissor lift through a doorway. The employee was pinned between the scissor lift and the doorframe, sustained a back injury, and was hospitalized.
COLUMBUS, OHIO—
American Electric Power Company
An employee was setting up communication equipment for a meeting. They were walking and tripped over a speaker on the ground. The employee sustained a leg injury.