BOWLING GREEN, OHIO—
VEHTEK SYSTEMS INC.
Compressed or pinched by shifting objects or equipment · Amputations
At a glance
Federal OSHA recorded a severe workplace injury at VEHTEK SYSTEMS INC., 2125 Wood Bridge Blvd. , BOWLING GREEN, OHIO 43402 on — Amputations, affecting the finger(s), fingernail(s), n.e.c..
Final narrative
On February 1, 2016, an employee was unloading parts from a conveyor when the conveyor stopped because a part was stuck upstream. The employee attempted to retrieve the part when a piece of steel began to index, got caught, and pinched her finger. Her right thumb was amputated.
More severe injuries at VEHTEK SYSTEMS INC.
BOWLING GREEN, OHIO—
Vehtek Systems Inc.
At about 9:45 a.m. on March 10, 2025, an employee was using a 5-ton overhead crane to move a right-hand check fixture, weighing 5,150 pounds, in a coordinate-measuring machine lab. As the crane lifted the fixture, the metal sling securing the fixture slipped over the employee's left thumb. The thumb was crushed between the metal slip and fixture, and the last joint was amputated.
BOWLING GREEN, OHIO—
Vehtek Systems Inc.
On September 19, 2024, an employee was assisting with a die changeover on a 2,000-ton press when the press was cycled, causing their hand to be pinched and resulting in an amputation to their ring fingertip.
BOWLING GREEN, OHIO—
Vehtek Systems Inc.
On May 13, 2024, an employee was polishing a piece of metal using a lathe when his glove became caught in the metal part pulling his hand into the machine. A few of the employee's fingers were fractured and dislocated.
BOWLING GREEN, OHIO—
Vehtek Systems Inc.
On January 10, 2024, at approximately 6:00 p.m., an employee was attempting to remove a part that was stuck to the conveyor of an 800-ton press. The employee's right index finger was pinched between the part and the conveyor guide, resulting in a fingertip amputation.
BOWLING GREEN, OHIO—
Vehtek Systems Inc.
On November 15, 2023, at 11:30 PM, an employee was walking through the facility. He went through a gate and went a further 2 or 3 steps when his right foot was run over by a forklift. The employee's foot was crushed and required hospitalization and surgery.
View VEHTEK SYSTEMS INC.'s full OSHA safety record →
Similar incidents · Same event type
MECHANICSBURG, PENNSYLVANIA—
TForce Freight
An employee was operating a forklift and unloading a truck. After the truck was unloaded, the employee got off the forklift and proceeded to adjust the dock plate with a hook tool. The dock plate slipped and the employee went to adjust the plate with their hand when their left middle finger got caught. Their finger was amputated above the first joint.
DELAWARE CITY, DELAWARE—
Liveo Research, Inc.
An employee was rotating a carbide granulator blade when his finger was caught between the blade and a stationary part of the machine. The employee's right middle finger was partially amputated and they suffered an avulsion to the right ring fingertip.
FORT WORTH, TEXAS—
Best Pump and Flow
An employee was using a CNC metal lathe machine in manual mode to check that the thread blocking tool made contact with the jaws. As the employee was manually spinning the spindle, his index fingertip was crushed between the spindle's jaws and the grooving insert, resulting in a fingertip amputation.
BUFFALO, NEW YORK—
FORD MOTOR COMPANY
During a material handling operation, an employee's fingertip was caught under an air conditioning unit as the unit was lowered onto a cart. The employee's fingertip was amputated.
UNADILLA, GEORGIA—
Lasseter Tractor Company. Inc.
An employee was removing a bolt from a tractor hub when their right index finger was caught between the hub and the frame. The employee's fingertip was crushed and the employee was hospitalized.
More severe injuries in this industry (NAICS 336370)
CORRY, PENNSYLVANIA—
Associated Metal Forming Technologies
An employee was verifying light curtain function at a load cell tester when their right index finger was amputated by a hydraulic cylinder above the middle knuckle.
OTTOVILLE, OHIO—
Progressive Stamping, Inc.
An employee was positioning an overhead crane to stand up a skidded coil when the coil swung back. The employee was caught between the swinging coil and another coil sitting on a coil pad, resulting in hospitalization due to a loss of consciousness and a pelvic injury.
SOUTH CHARLESTON, WEST VIRGINIA—
Gestamp
An employee was performing general cleanup duties when they collapsed and passed out due to heat exhaustion. They were hospitalized for heat exhaustion, dehydration, and acute renal failure.
WEST JEFFERSON, OHIO—
Jefferson Industries
A temporary employee was helping a forklift operator by holding metal sheets to steady them as they were placed on a rail for feeding to a stamp machine. The operator lowered the forks with the blanks (weighting approximately 750 pounds). The temporary employee's right index finger was caught between the metal and the feeding rail. The finger was crushed and partially amputated through the bone.
UTICA, NEW YORK—
Utica Metal Products, INC.
An employee was using a mechanical trim press to trim flash off metal parts. The employee was loading a part to be trimmed when the press cycled and crushed the index fingers on both of their hands. The employee sustained a fingertip amputation. The machine was not guarded at the time.
More severe injuries in OHIO
DAYTON, OHIO—
United States Postal Service
An employee was working to deliver mail to an apartment building. She was waiting for a customer to move, to obtain clearance to the mailboxes. The door swung inward and closed on her right little finger. The top half of her finger was surgically amputated.
COLUMBUS, OHIO—
Foundation Steel, LLC
An employee fell from a step ladder while reaching for a tie-off point. He impacted the ground, and landed on his bolt bag which contained tools. The employee was hospitalized with fractured ribs, and a lacerated spleen and kidney.
LIMA, OHIO—
GXO Logistics
On October 30, 2025, an employee was working to adjust a stackable metal shipping container. As the container dropped into place, it caught the employee's hands in an area between the upper and lower cross-members. The employee suffered a laceration to the left ring finger that required stitches, bruising to the right ring finger, and fractures to the right middle finger that necessitated medical amputation of the fingertip.
CANTON, OHIO—
Abbott Electric Inc
An employee was moving a scissor lift through a doorway. The employee was pinned between the scissor lift and the doorframe, sustained a back injury, and was hospitalized.
COLUMBUS, OHIO—
American Electric Power Company
An employee was setting up communication equipment for a meeting. They were walking and tripped over a speaker on the ground. The employee sustained a leg injury.