Weyerhaeuser

During a maintenance day, two operators locked out the lathe to replace the trash gate cylinder. To complete the lockout, the lathe operator raised the trash gate to the pin position while another operator inserted a pin for the gate to rest on while the work is performed. When this event occurred, the lathe operator was in the cab, and the other operator was at the trash gate with the blocking pin. While inserting the pin, the gate rose from the run position to the pin position, pinching the injured employee's left middle finger and resulting in a fingertip amputation.

An employee was emptying a self-emptying trash dumpster. When the lever came down onto the track that guides the hopper into the dumping position, the employee sustained partial amputations to the right middle and index fingers.

An employee was climbing onto the outfeed roll case of a band mill. His left hand was on a 4-inch square tubing support beam as he stepped onto a bottom rail of the handrail. The handrail was attached to a set of steps, which tilted up. His left ring finger was smashed between the handrail and the square tubing. His fingertip was amputated.

An employee was operating a three-wheeled personal electric transport vehicle. While traveling up a concrete grade of approximately 30 degrees, the equipment failed. The employee then attempted to turn left, back down the incline, and the front wheel may have caught on a concrete barrier. The employee fell out of the vehicle, landed on the concrete ground and sustained a broken left femur.

As an employee was walking to his work station, he saw two boards misaligned on the green trimmer conveyor belt. When he reached to align the boards his left pinky finger was jammed between the conveyor belt wall and the boards. His left pinky fingertip was surgically amputated.

An employee was unnesting tote bags when her grip slipped and the back of her left hand hit a box containing a steel step stool that was adjacent to the tote bags. The employee's hand was fractured.

An employee was cleaning up and putting away equipment when the second toe on her right foot was stubbed on a fixture, resulting in hospitalization and a subsequent amputation of the toe.

An employee was walking when he tripped on a concrete vault lid, jamming his big toe into the tip of his steel toe boots. The employee's big toe was medically amputated.

An employee was cleaning a bathroom. As the employee bent over, the corner of a sink hit the employee's right eyeball, causing an injury that required hospitalization and surgery.

On September 23, 2023, an employee was cleaning near a conveyor when they knelt with their right knee on the floor. Their knee contacted a small piece of glass on the floor, resulting in a laceration that required hospitalization.

An employee was using a water hose to clean debris out of the outfeed of a log conditioning vat. Water began entering the vat from the adjoining vat through a void in the separation wall at the infeed of the vats. As the employee was exiting the vat he had been working in using the access opening at the outfeed, hot water exiting the access opening entered the top of his protective hip wader. It pooled at the bottom of the wader and burned his left foot and ankle.

On August 31, 2025, an employee was pulling a belt around a pulley when their right ring finger was caught between the pulley and the belt for the underdraft fan. The finger was lacerated and the employee was hospitalized.

An employee was on a ladder, pruning a tree in the outside picnic area. The employee lost their balance and fell. The employee was hospitalized with a fracture to their lower left leg.

On May 8, 2025, an employee was dumping a trash hopper while operating a forklift. His left hand was caught in a pinch point on the bottom of the trash hopper, resulting in a partial amputation to the index fingertip.

An employee was cleaning an air station with a pressure washer when the water stream went through their boot and contacted their left foot, resulting in a 1.5 inch by 1 inch laceration to the top of the foot.

An employee tripped over a concrete curb stop in a parking lot. The employee fell to the ground, landing on their left hip and breaking it.

An employee was conducting routine maintenance on a mixer. New lid pins had been installed, and the employee was rotating by hand to ensure they had been installed correctly. The employee's left middle finger was caught between the lid and top of a pin. The momentum from the mixer continued, causing a crushing injury to the finger. The employee underwent a medical amputation from the top knuckle to the tip of the finger.

An employee was climbing down a ladder when it slipped. The employee fell, suffering a broken scapula and broken ribs. The employee was hospitalized.

An employee was climbing down a 15-foot multipurpose ladder. The employee fell about 8 feet, landing on the concrete floor and the ladder itself. The employee suffered several injuries, all on the right side: broken ribs, a broken sternum, a broken temporal bone, broken shoulder, multiple fractures to the cheekbone, and a brain bleed.

An employee was rolling up the landing gear on his trailer when the handle began to unwind and struck his face, fracturing his jaw. The employee was hospitalized and required surgery.