Fall on same level due to tripping over an object · Amputations
At a glance
Federal OSHA recorded a severe workplace injury
at Georgia Pacific Corporation, 1919 S. Broadway , GREEN BAY, WISCONSIN 54304
on — Amputations, affecting the finger(s), fingernail(s), n.e.c..
Final narrative
An employee was walking and got their left foot caught on a portable set of steps that are along the bottom of the table on the north side. The employee attempted to break the fall and their right hand was caught in a machine amputating the right finger up to the first knuckle.
An employee was rearranging unit stacks inside a trailer. He stepped onto one unit (5.5 feet tall) to push the unit behind it. The employee fell between the two units onto the floor of the trailer, resulting in five broken ribs on the left side and a punctured left lung.
An employee was clearing a fault on her machine when she slipped on preprint corrugated sheets lying on the floor and fell to the concrete floor. She sustained a fractured right hip and a bruised right wrist.
An employee was removing a 6' x 6' cover from a log chipper using a hoist. The chipper disc contacted the cover which then dislodged from the hoist and struck the employee, resulting in lacerations to the head, neck and face and broken teeth.
An employee was repairing a sight glass on a water holding tank and noticed a leaking pipe that needed repair. He stepped onto a 3-inch pipe and his wrench fell, causing him to lose balance. The employee fell onto a mixer motor and landed on the floor. The employee sustained a fractured left wrist, fractured left clavicle, and five fractured ribs.
An employee was helping to remove a tote filled with ink when the tote contacted his left hand and pinched his finger between it and a metal frame, amputating his fingertip.
An employee arrived at work and was walking into the store through the parking lot. The employee tripped over a curb and fell to the ground, sustaining a femur fracture.
An employee was clearing a material jam on a line, at a point where it formed the cores of diapers. When he removed the material, his left little finger was caught between the belts of a forming drum. His hand was lacerated and the finger was broken. He was hospitalized, requiring surgery. The machine was guarded at the time of the incident.
On April 9, 2025, an employee was cleaning anilox rollers in a machine with a rag. The machine caught the rag and then the employee's left hand, resulting in amputation of the middle finger.
An employee was jogging two rollers to clear a paper jam when his left hand was pulled into the rollers, resulting in amputations of the index, middle, and ring fingers down to the knuckle.
On July 27, 2024, at 2:45 AM, an employee was walking down an aisle in the converting department when he tripped and fell on the ground. The employee was hospitalized with a fractured left hip.
The injured employee was assisting five other employees with bracing a wall panel that was being stood up. Another employee slipped on frost on the floor surface. The employees went to evacuate the area in anticipation of the wall panel falling over. The injured employee went to jump through a window opening within the wall panel and their lower half was crushed by the falling wall panel. The employee sustained a fractured pelvis.
An employee was using a vertical band saw to cut a thick piece of rubber material. While being cut, the material shifted, causing the employee s right hand to contact the moving blade. The employee's thumb was amputated below the knuckle. The employee was hospitalized, undergoing surgery.
A production sanitation employee was pre-rinsing an incline conveyor and noticed cheese stuck between the belt idler. The employee went to remove the cheese and their glove got caught and pulled their left forearm into the conveyor. The employee's arm was fractured. The machine was not locked out/tagged out at the time.
An employee was on a ladder, taking measurements for a new gutter installation. The ladder slipped out from under him and both he and the ladder fell to the ground. He was hospitalized with seven broken ribs and a broken clavicle.
An employee was unloading a truck for a delivery job. While moving boxes in the truck, the employee tripped over a pallet and fell out of the truck to the ground, resulting in four broken ribs.