Fall through surface or existing opening more than 30 feet · Fractures
At a glance
Federal OSHA recorded a severe workplace injury
at Gavilon Grain, LLC, 2203 21st Rd, CLARKS, NEBRASKA 68628
on — Fractures, affecting the multiple body parts, n.e.c..
Final narrative
On October 29, 2016, an employee went to the top of the bin and opened the manhole hatch to repair the sweep auger. The employee was later discovered at the bottom of the bin approximately 80 feet below the opening. The employee suffered a broken left leg and fractured vertebrae.
HospitalizedMultiple body parts, n.e.c.Tanks, bins, vats-nonconfined space
An employee was sweeping grain and got caught in the drag chain conveyor after stepping into an opening in the walking surface. The employee suffered the surgical amputation of three toes on the left foot.
An employee was removing a re-framed wall stud section on the fourth level of a building. He stepped backward and fell 40 feet down a grease chute to the concrete floor. The employee was hospitalized with swelling and bleeding above his right eye and internal injury to the pancreas.
On 1/06/2023, an employee was on the fourth floor flat roof of an apartment building construction worksite. The employee was cleaning up nails and trash and putting them in a trash bag. The employee fell through a hole on the fourth floor and landed on the concrete floor of the first floor. The employee sustained a broken right ankle and required back surgery.
An employee was putting a tarp over a leak in a concrete roof. The employee fell through the roof to the floor 32.5 feet below, suffering a broken collarbone and leg, as well as a spinal injury that required a pin.
An employee was preparing to unjam an auger shaft while standing on a forklift-elevated, job-made platform. The employee's wrench slipped off the equipment, causing them to lose their balance and fall. The employee landed on the ground 14 feet below and suffered fractures to the orbital bone, left elbow, and lower back.
An employee was walking past a crossover conveyor when a ramp came down and hit them in the back. The employee sustained a broken back vertebra, as well as a concussion, and was hospitalized.
An employee bent over to pick up a rubber mat from the ground. When he grabbed the corner of the mat, a rattlesnake hidden under it bit his left middle finger near the first knuckle. He was hospitalized.
An employee had been cleaning a grain bin. He walked across the bin and his left foot contacted an unguarded floor auger, resulting in severe lacerations to the foot. The auger was not locked out/tagged out at the time.
On September 23, 2025, an employee was monitoring a feed roller when they tripped and their right hand contacted the roller. The employee was hospitalized and their right hand was amputated at the wrist.
An employee was stacking concrete blocks for a concrete bunker. As a block was swinging into place, the employee's left leg was pinched between two blocks, resulting in injuries to his left heel and lower leg.
An employee was climbing a ladder to inspect a vent in a restaurant dining area. The ladder slid out on the floor and the employee fell approximately 12 feet onto the ladder and the floor. He was hospitalized with a dislocated shoulder and a back injury.
An employee was filtering a fryer with a fryer filter machine. After going around the corner and then returning to the fryers, the employee stepped into the filter machine. The hot oil burned the employee's right ankle, and the employee was hospitalized.
An employee was cleaning out corn from a grain bin. The sweep auger in the bin was activated and caught his trouser leg. His leg was pulled into the auger, which injured his calf and caused leg fractures and lacerations.