Fall on same level due to tripping, unspecified · Amputations
At a glance
Federal OSHA recorded a severe workplace injury
at Old Bridge Chemicals, Inc., 554 Waterworks Road, OLD BRIDGE, NEW JERSEY 08857
on — Amputations, affecting the fingertip(s).
Final narrative
On 7/19/17, an employee was cleaning near a zinc sulfate bagging operation when the employee tripped. The employee's right hand then entered the rotary air valve and contacted rotating parts, amputating the index fingertip.
AmputationFingertip(s)Floor, n.e.c.
More severe injuries at Old Bridge Chemicals, Inc.
An employee was standing between two digesters drawing a sample from one digester when the hot copper sulfate solution erupted from the other digester and splashed onto the employee's back. The employee sustained third degree burns on their back.
An employee was walking down the hall to retrieve a vacuum when they stumbled and fell to the floor. The employee suffered wrist bruises and a kneecap fracture that required surgery.
An employee was installing a compressor piston. He tripped and fell backward while the piston was in his lap. As he landed, the little finger of his left hand became caught between the piston and compressor piping resulting in a partial amputation of the fingertip. The employee required stitches and the fingertip was reattached.
An employee was doing an oil change. He was walking to get his oil jug when he tripped on an open lift pad, and fell to the ground landing on his right side. The employee sustained a broken right femur and was hospitalized.
More severe injuries in this industry (NAICS 325180)
An employee was on a ladder disconnecting a 1-inch hose, known to have last carried acrylic acid that had been drained. When the hose was disconnected, residual acid dripped onto the employee's shoulder/arm area, causing a second-degree chemical burn.
On October 1, 2025, at approximately 9:50 p.m., an employee was removing a sack of debris from a dust collector when four of his right-hand fingers were severed by a rotary valve. The employee was hospitalized and underwent surgery to amputate the four fingers at the knuckle.
An employee was unloading and depressurizing a railcar filled with sulfuric acid. The employee turned the valve to disconnect the hose when sulfuric acid released and sprayed upward via the standpipe. The employee was hospitalized burns.
On May 8, 2025, an employee developed a cough while cleaning up chemical sewage from the floor. He was hospitalized, having suffered an allergic reaction to chemical product vapors.
An employee was loading a magazine of tubes into a machine to fill. As they raised the door into position, the door dropped onto the employee's right hand and amputated their right index fingertip at the nailbed.
An employee was installing fence posts when they stepped into a recently dug hole that was not visible due to rainfall. The employee's leg was fractured.
An employee assisted in cleaning material from a conveyor pit. After the pit was cleaned, the employee proceeded to replace metal safety plates to ensure other employees did not fall into the pit. While replacing one of the last plates, the employee mis-stepped and fell approximately 5 feet into the pit. The employee was hospitalized with back/side bruising, elbow bruising, bone bruises, and/or fractured ribs.
An employee was walking on the sidewalk. When they stepped off the curb, they fell to the ground, resulting in fractures to their tibia, fibula, and a metatarsal.