Other jump to lower level, unspecified · Fractures
At a glance
Federal OSHA recorded a severe workplace injury
at Demountable Concepts Inc., 200 Acorn Road, GLASSBORO, NEW JERSEY 08028
on — Fractures, affecting the knee(s) and leg(s).
Final narrative
An employee was using a crane to move loads of pipe from the shop floor onto the shelving system in the warehouse. He noticed that one of the pipes in the load was stuck on the lip of the warehouse shelf. He climbed a step ladder and attempted to unhinge the pipe using a crowbar. When he used the crowbar, the load began to shift on the shelf and he jumped from the ladder to avoid it, landing on his left leg on the concrete shop floor. He fractured his left knee and tibia and was hospitalized.
Four employees were attempting to modify an approximately 10 ft. high by 10 ft. long non-assembly single piece metal scaffold system on wheels and lay it on its side in order to replace 2 x 8 wooden platforms. The scaffold kicked out while the employees were tipping it over and the scaffold fell onto an employee's left leg resulting in a compound fracture.
An employee was crossing over a sorting belt and jumped down onto the catwalk next to the belt. The employee sustained a right ankle fracture and dislocation.
On November 7, 2023, at 6:00 PM, an employee was getting off a roof at the end of the work day. He missed a step and then jumped from the ladder to the ground sustaining a fractured ankle.
An employee was on the table of a machine. She went to jump down from the table and fractured her lower leg on the ground. The employee was hospitalized.
An employee was loading a flatbed trailer when a forklift bumped into the trailer. A wheelset began to roll in his direction and the employee jumped off the trailer to avoid it. The wheelset caught him on the leg and he landed on his shoulder on the ground. He sustained a laceration below the left kneecap and a dislocated shoulder.
An employee was changing a die in a press when the die slipped and crushed the employee's left index finger. The employee sustained an open facture of the tuft of the left distal phalanx and a partial amputation.
An employee was assisting with rigging a magnet to an overhead crane in order to lift a sheet of steel. The employee's right thumb was between the crane's hook and the chain passing through the hook, and when the crane was raised, the distal end of their thumb was crushed. Part of the employee's right thumb was medically amputated.
Two employees were working together to insert a pin into a hydraulic cylinder. One employee was holding the cylinder in place to align it with the pinhole, while the injured employee was inserting the pin. The injured employee was aligning the pin and moved to determine whether the hole alignment was too high or low. At that moment, the crowbar being used to assist with alignment slipped and his left index fingertip was pinched between the cylinder and the housing, resulting in an amputation just below the fingernail.
An employee was hoisting an axle in the buggy department when one side of the sling came loose, causing the axle to tip. The sling hook raised up from the weight transfer, causing the employee's left little finger to be caught by the rigidness of the hook. The fingertip was amputated.
An employee was using a circular saw to cut the cap off an aluminum bulkhead of a trailer that was being manufactured. The saw kicked, lacerating his hand and resulting in the amputation of his left middle and ring fingertips.
An employee was installing fence posts when they stepped into a recently dug hole that was not visible due to rainfall. The employee's leg was fractured.
An employee assisted in cleaning material from a conveyor pit. After the pit was cleaned, the employee proceeded to replace metal safety plates to ensure other employees did not fall into the pit. While replacing one of the last plates, the employee mis-stepped and fell approximately 5 feet into the pit. The employee was hospitalized with back/side bruising, elbow bruising, bone bruises, and/or fractured ribs.
An employee was walking on the sidewalk. When they stepped off the curb, they fell to the ground, resulting in fractures to their tibia, fibula, and a metatarsal.