Caught in running equipment or machinery, n.e.c. · Amputations
At a glance
Federal OSHA recorded a severe workplace injury
at Tetra Pak Materials LLC, 3300 Airport Road, DENTON, TEXAS 76207
on — Amputations, affecting the fingertip(s).
Final narrative
An employee was attempting to check a discharge pipe on a rotary seal machine when the employee's glove was caught by the rotary seal blade. The blade then amputated the employee's right middle fingertip.
Employees were conducting an annual separator service for a customer. An engineer was replacing a sliding bowl into a separator when his left thumb was pinched between the sliding bowl and the bowl body as a crane lifted it. His thumb tip was amputated above the bone.
At about 12:45 a.m. on August 6, 2021, an employee was trying to dislodge paper stuck inside a rotating valve on a bagger. The blade in the valve was activated, rotated, and amputated the employee's right index and middle fingers.
An employee was preparing packaging reels for slitting when reels that had been recently cut rolled off a table and struck the employee, fracturing the hip.
Employees were assembling and testing a butterfly valve unit and actuator combo. When the unit was function tested with air, the valve gate closed on an employee's left thumb resulting in a fracture and laceration.
An employee was doing a daily inspection of the sifter screen on a mixer when the mixer line activated. The armature for the screen struck the employee's right wrist. Their wrist was cut and their hand was fractured.
An employee was doing a dry run during the setup of an ice cream machine. The machine indexed and the filler head amputated the employee's left middle finger above the last knuckle.
An employee was on a 3-foot ladder guiding cable onto a spool during installation on an overhead door. As the control box was jogged, the employee's hand was caught between the cable and spool, resulting in a wrist and hand fracture.
More severe injuries in this industry (NAICS 322221)
At 12:45 a.m. on September 21, 2025, an employee was working to clear an obstruction in a machine when his left hand came into contact with a turning screw inside the machine. His index and middle fingers were amputated.
Two employees were changing out a mandrel on a coater converting machine when the injured employee's right index fingertip was pulled by the mandrel, resulting in a partial amputation.
On August 18, 2023, at 10:15 p.m., an employee was chucking a core when their left little finger got caught between the chuck and the core, resulting in amputation.
On August 10, 2023, at approximately 6:45 PM, a maintenance employee was replacing a cover on an electric motor when the motor assembly dropped to the floor, crushing the employee's right little finger and amputating the fingertip.
An employee was performing maintenance on a sheeter. He had pried up a steel access plate and was lifting it when it slipped and fell on his left middle finger. The finger was pinched against the floor, and part of the fingernail and fingertip was amputated.
After cutting a slab of beef short ribs, an employee turned to grab the pieces he had cut and his right hand contacted the saw blade. The employee sustained an amputation to his right index finger.
An employee was unloading a carpet pad from a truck when they fell from the truck dock to the concrete below, resulting in five fractured ribs and an injury to their left lung.
An employee was walking up a walkway to enter a building through the back entrance when she tripped over the lip of the cement ramp. The employee fell and sustained a fractured right hip.