BIG VALLEY PRODUCTIONS

An employee was walking along a trench inspecting the trench box in the excavation when he tripped and fell toward the trench. As the employee was falling head-first into the trench, he attempted to get a hold of the fall protection cable. The cable then looped around his left hand and the employee fell approximately 8 feet into the trench before the fall protection engaged. The employee suffered amputations of his left index, middle, ring, and little fingers.

A ranger was performing back-country patrol duties while hiking. As they were climbing a technical rock patch, a rock handhold broke, causing the employee to fall approximately 15 feet before their belay engaged. The employee contacted a rock, resulting in a fracture to the right ilium as well as a subcutaneous hematoma to the right gluteal region.

Employees were erecting structural steel. The injured employee was sitting on a 12" wide horizontal member and lining up an I-beam brace as it was suspended by an overhead crane. He leaned left to push the end of the brace. The end of the suspended brace swung away from him, causing him to lose balance and fall 8 feet. His personal fall arrest system arrested his fall, but he swung into a piece of duct work during the fall that resulted in a concussion.

On September 12, 2022, an employee was on a metal roof, installing a standing seam and insulation. He lost his balance and fell toward the third floor slab, which was 10 feet from the roof. His fall protection caught him and left him suspended about 2 to 4 feet from the slab. He suffered a brain bleed and a spinal fracture in his lower back. He was hospitalized.

An employee was working from a bucket lift, removing a tree in sections. He lost his balance while pushing on a section and fell. His fall protection caught him and he swung into a tree, suffering an injury that caused head, neck, and leg pain, as well as loss of consciousness while he was at the hospital.

An employee was working as a background extra for a movie. She slipped while walking through the holding/catering area, falling to the ground and striking her right elbow. The employee was hospitalized with a fractured elbow.

An employee was dismantling a film set. He was standing on top of a wooden beam when he lost his balance and fell approximately 10 feet to the ground below, striking his head on a standing light. He sustained injuries to his head, torso, and shoulders. A guardrail was in place at the time of the injury.

An employee had been sitting in a truck that was not on and had no air conditioning. The employee felt ill and was hospitalized for heat illness.

A photographer was walking through a studio toward the production table during a photoshoot. The photographer tripped on a power cord that was taped in place on the floor with a cord cover. The photographer fell, fractured her right hip, and was hospitalized.

An employee was on a temporary loading dock, receiving pieces of a large tent structure from a telehandler. She was working to straighten a packing blanket when the telehandler lowered it's tines onto her left hand. Her middle finger was degloved from the first knuckle up. The finger required surgical amputation from the first knuckle up.

An employee was helping to lift the grating from a floor draining system when the grating slipped and landed on his hand, resulting in the amputation of his right middle finger at the first joint.

A casting machine jammed. An employee's hand was caught in the machine, where a belt line caught and amputated the tip of his finger.

During a workshop meeting in a hotel, an employee heard a drilling noise, so he walked outside to see what it was. An explosion occurred (possible gas line) and his face, ear, and hair were burned. He also fell and sustained a pelvic fracture.

An employee slipped on condensation on a walkway in a parking garage. She fell and suffered a closed fracture to the neck of the left femur.

An employee was using a tool to remove a rag from a roll on the tube mill. The roll pulled the tool and the employee's right hand into the roll, resulting in a partial amputation of the little finger and a fracture to the index finger.