Fall or jump curtailed by personal fall arrest system · Traumatic injuries and disorders, unspecified
At a glance
Federal OSHA recorded a severe workplace injury
at Sid Richardson Carbon Co, 5221 Sid Richardson Road, ADDIS, LOUISIANA 70710
on — Traumatic injuries and disorders, unspecified, affecting the nonclassifiable.
Watch Sid Richardson Carbon Co — freeGet an email when a new federal OSHA severe-injury report for Sid Richardson Carbon Co is published. One employer, no account, unsubscribe in one click.
Final narrative
An employee was grabbing samples on a railcar. As he stood up, he slipped and fell chest downward, then began to slide on the downward slope of the car. He then attempted to turn his body and grab something but went over the side of the car. The webbing attached to the locking snap hook on his safety harness D-ring popped, and he felt a jerk before landing on the ground feet first and suffering an injury.
An employee was walking along a trench inspecting the trench box in the excavation when he tripped and fell toward the trench. As the employee was falling head-first into the trench, he attempted to get a hold of the fall protection cable. The cable then looped around his left hand and the employee fell approximately 8 feet into the trench before the fall protection engaged. The employee suffered amputations of his left index, middle, ring, and little fingers.
A ranger was performing back-country patrol duties while hiking. As they were climbing a technical rock patch, a rock handhold broke, causing the employee to fall approximately 15 feet before their belay engaged. The employee contacted a rock, resulting in a fracture to the right ilium as well as a subcutaneous hematoma to the right gluteal region.
Employees were erecting structural steel. The injured employee was sitting on a 12" wide horizontal member and lining up an I-beam brace as it was suspended by an overhead crane. He leaned left to push the end of the brace. The end of the suspended brace swung away from him, causing him to lose balance and fall 8 feet. His personal fall arrest system arrested his fall, but he swung into a piece of duct work during the fall that resulted in a concussion.
On September 12, 2022, an employee was on a metal roof, installing a standing seam and insulation. He lost his balance and fell toward the third floor slab, which was 10 feet from the roof. His fall protection caught him and left him suspended about 2 to 4 feet from the slab. He suffered a brain bleed and a spinal fracture in his lower back. He was hospitalized.
An employee was working from a bucket lift, removing a tree in sections. He lost his balance while pushing on a section and fell. His fall protection caught him and he swung into a tree, suffering an injury that caused head, neck, and leg pain, as well as loss of consciousness while he was at the hospital.
More severe injuries in this industry (NAICS 324199)
An employee was preparing an oven for charging and cracked the seal of the jump lid to release pressure. Flames unexpectedly released from the oven and burned the employee's right ring and little fingers. The employee sustained second-degree burns.
An employee was starting to work on the change of a conveyor belt and experienced symptoms of heat exhaustion due to high temperatures. The employee was hospitalized with heat exhaustion and dehydration.
An employee had been working to fill lump charcoal into 40-pound bags when the crusher jammed. He was standing at the filling station and went to clear the machine. The employee's gloved right hand was pulled into a belt and pulley, causing the amputation of his little finger and a severe laceration to his ring finger. The employee was hospitalized and required surgery. The machine was guarded and locked out/tagged out at the time.
An employee was uncoupling a hose from an air compressor. The pressurized hose struck the employee's left side, fracturing a rib and lacerating their kidney and spleen.
A driver was exiting his vehicle outside the plant gate when his foot slipped on the top step of the truck. He fell to the ground, landed on his left hip and elbow. The employee was hospitalized with a fractured hip/femur.
A security employee was responding to an urgent call from staff regarding a violent patient. The employee tripped and fell on the floor outside of the stairwell. The employee sustained a closed head injury, contusion of the cerebrum without loss of consciousness, and a closed fracture of the distal end of the right radius.
A temporary employee was testing an electrical starter motor. He was placing tape on the starter while the breaker was not engaged, but the starter sent an arc flash that burned his hands and stomach.
An employee was walking on a sidewalk and stubbed his toe on an elevated portion of concrete, causing him to trip and fall. The employee's right knee was dislocated.