WATERTOWN, MASSACHUSETTS—
Tesla, Inc.
Struck by falling object or equipment, n.e.c. · Traumatic injuries and disorders, unspecified
At a glance
Federal OSHA recorded a severe workplace injury at Tesla, Inc., 457 Pleasant Street, WATERTOWN, MASSACHUSETTS 02472 on — Traumatic injuries and disorders, unspecified, affecting the nonclassifiable.
Final narrative
Two employees were removing a battery from a vehicle when the battery fell from the vehicle, striking both employees. One employee was hospitalized.
More severe injuries at Tesla, Inc.
AUSTIN, TEXAS—
Tesla, Inc.
An employee was inspecting a casted part that weighed 330 pounds. The part fell from a lift assist onto the employee, striking his upper right arm and head. He suffered burns to the upper right arm and was hospitalized.
AUSTIN, TEXAS—
Tesla, Inc.
On June 4, 2025, an employee was skimming molten aluminum when it dripped down from the skimming spoon onto the employee's left pant leg, burning the top of their left foot. The employee was hospitalized and required surgery.
AUSTIN, TEXAS—
Tesla, Inc.
An employee was loosening the legs of a metal desk on the production floor to adjust the height when the desk collapsed onto the employee's right hand, resulting in amputation of the thumb tip.
AUSTIN, TEXAS—
Tesla, Inc.
An employee was transferring molten aluminum into a sow (mold). Condensation dripped from a pipe located above the area into the sow as it was staged to fill. When the molten aluminum came into contact with the water, the molten aluminum reacted and was released into the air, contacting the employee. They sustained burns to their chest, neck, and bilateral upper extremities.
AUSTIN, TEXAS—
Tesla, Inc.
An employee was using a ladder to access a roof to install conduit pipes when the ladder slipped on patio tile and came out from under him, causing him to fall approximately 8 feet to the ground. The employee suffered a spinal fracture and brain bruising.
View Tesla, Inc.'s full OSHA safety record →
Similar incidents · Same event type
PORT ALLEN, LOUISIANA—
Performance Contractors, Inc.
An employee was moving a piece of an I-beam for welding when it rolled off the cribbing. The employee went to catch it when it fell and crushed the employee's finger, resulting in a partial amputation.
KIRKSVILLE, MISSOURI—
WIRECO WORLDGROUP, INC.
An employee was helping to disassemble large reels used to store steel wire when a 264-pound flange from the reel fell over onto the employee's left leg. The employee sustained multiple fractures to their leg and ligament injuries to the lower leg.
GREENSBURG, PENNSYLVANIA—
Owens & Minor - Pittsburgh Distribution Center
The injured employee was putting away materials on the warehouse floor as a co-worker was pushing a pallet onto a nearby shelf. The pallet knocked another pallet forward, causing it to fall onto the injured employee's shoulders. The employee suffered fractures in their right and left knees and ankles.
FORT BLISS, TEXAS—
Retro Tech Systems
Employees were moving a single man lift into a building and reclining the lift to position it to fit through the door. The lift shifted and fell, causing the employee to sustain fractures to the left tibia and fibula. The employee was hospitalized and had surgery.
ORLA, TEXAS—
Creston Energy Group
An employee was moving a light tower so it could be hitched to a truck. He grabbed the tongue of the trailer hitch on the light tower to slide it to the left. The tongue jack fell off, causing the light tower tongue to drop on the employee's right hand. The employee's middle fingertip was amputated.
More severe injuries in this industry (NAICS 336111)
AUSTIN, TEXAS—
Tesla Giga Factory
An employee was using a battery-powered torque tool to fasten a bolt. The tool was activated and the socket of the tool rotated and pulled in their gloved left hand. The employee sustained a left index fingertip amputation.
AUSTIN, TEXAS—
Tesla, Inc.
An employee was inspecting a casted part that weighed 330 pounds. The part fell from a lift assist onto the employee, striking his upper right arm and head. He suffered burns to the upper right arm and was hospitalized.
THE COLONY, TEXAS—
Tesla Distribution Center
An employee was reaching to hook her harness into a lanyard and began to experience abdominal pain. The employee sustained an umbilical hernia.
AUSTIN, TEXAS—
Tesla, Inc.
On June 4, 2025, an employee was skimming molten aluminum when it dripped down from the skimming spoon onto the employee's left pant leg, burning the top of their left foot. The employee was hospitalized and required surgery.
SANDUSKY, OHIO—
Ventra Sandusky LLC
On June 3, 2025, the injured employee was setting a mold with a co-worker when the mold was displaced and caught their right hand against the stop block. The employee sustained a fracture and partial amputation of their middle finger.
More severe injuries in MASSACHUSETTS
CHICOPEE, MASSACHUSETTS—
A&S Services Group
An employee fell while exiting a trailer. The employee landed on their left side on the pavement, suffering multiple broken ribs on the left side. The employee was hospitalized.
BILLERICA, MASSACHUSETTS—
American Flowform and Machining, LLC
Two employees were setting up a mandrel in the spindle of a machine. The mandrel was side-shifted while an employee's hand was on the mast of a powered industrial truck. The employee suffered crushing injuries that resulted in amputations to the middle and ring fingertips.
NEW BEDFORD, MASSACHUSETTS—
Acushnet Rubber Company, Inc
An employee had been loading a double deck press. The employee saw a mold had been sent in with the C-hook still attached on the belly bar. As he went to remove the hook from the mold, his right thumb got caught on the C-hook. The employee's thumb was partially amputated.
NORTHAMPTON, MASSACHUSETTS—
Warner Brothers, LLC
An employee was operating a roller and paving a small pathway next to a pavilion. The ground was on a slight pitch, causing him to reach up toward the roll cage to stabilize himself. His right fifth finger was pinched between the roll cage and the rafter of the pavilion. The employee sustained a partial degloving injury with partial traumatic amputation.
WEST WAREHAM, MASSACHUSETTS—
Roby's Propane Gas
An employee was delivering home heating fuel when bees came from the ground and stung the employee's face, neck, torso, and hands. The employee proceeded to shut off the oil flow before losing consciousness. They were hospitalized due to an anaphylactic reaction.