Fall through surface or existing opening 6 to 10 feet · Fractures
At a glance
Federal OSHA recorded a severe workplace injury
at Champion Home Builders, Inc., 1915A SE SR 100, LAKE CITY, FLORIDA 32025
on — Fractures, affecting the shoulder(s), including clavicle(s), scapula(e).
Final narrative
An employee was securing the roof of a manufactured home from the rear of a mobile scaffold when the scaffold moved, causing him to lose his balance as he was walking toward the catwalk. He then fell 9 feet to the ground through a gap between the mobile scaffold and the catwalk, fracturing his collarbone and requiring hospitalization.
HospitalizedShoulder(s), including clavicle(s), scapula(e)Existing floor opening
More severe injuries at Champion Home Builders, Inc.
At 7:30 a.m. on March 11, 2025, an employee was cutting angle iron pieces with a saw. When he went to stop the blade, it lacerated his right middle finger.
The injured employee was holding the rafters at the roof build table area while a co-worker attached them to the roof frame using a pneumatic nailer. A four-inch nail ricocheted and pierced the employee's left shoulder resulting in injury to an artery and the left lung.
An employee was using a miter saw to install molding during construction of a new mobile home and sustained severe lacerations to their right arm and hand.
An employee was standing on an A-frame ladder 3 to 4 feet above the ground, replacing the exterior siding of a home. The ladder tilted to one side, causing him to fall off. He suffered eight broken ribs and a collapsed lung.
An employee was laying out a 2-by-4 for railing on a second floor. The employee fell backward through an opening and landed on a concrete floor about 9.5 feet below, suffering broken vertebrae.
An employee was a spotter for a trap door that was being tested prior to a show. The trap door activated and the employee fell approximately 8 feet onto stunt mats that were covering the floor below. The employee sustained a fractured right shoulder, a dislocated right ankle, and a sprained left ankle.
An employee was moving a robot when they fell approximately 9 feet through a catwalk hole and landed on the floor. The employee sustained a head injury.
An employee was working in the attic of a modular home. As he was attaching a 2x4, the employee fell 9 feet through the ceiling to the ground. He sustained a fracture near the spinal cord.
More severe injuries in this industry (NAICS 321991)
On September 5, 2025, an employee was installing gang plates on a structure when the side walls fell and hit her head. She then fell onto her back and the side wall pressed her to the ground, resulting in hospitalization due to an ilium fracture and a transverse process fracture on the right side.
An employee was blowing cellulose insulation into the open attic area of a manufactured home. While the employee was holding the insulation hose, it caught on the guardrail of the catwalk/suspended walkway leading into the attic. The tugging motion caused the employee to lose their footing and step onto the sheetrock ceiling. The employee fell through the ceiling to the ground about 8 feet below and suffered a broken lower left leg. The employee was hospitalized.
An employee was going between a ladder and a wall to repair a wall in the utility room. A brad-nailing gun was hanging on a piece of wood on the side of the ladder. The employee contacted the brad nailer and the trigger was pushed into the wooden piece. The brad-nailing gun actuated and shot a 2-inch brad into the employee's abdomen.
An employee was on a scaffold caulking and painting a manufactured home. She fell off the scaffold an estimated 6 to 8 feet, landing on the concrete floor. The employee suffered upper body injuries and was hospitalized.
An employee was going up a ladder from the first level roof to the second level roof. The ladder slipped and the employee fell approximately 8 to 10 feet to the surface on the first level. The employee sustained fractures to three ribs and bruises on their arms and hands.
An employee was helping a coworker transport a tall palm tree with a mini skid steer. The employee was severely shocked by a high-voltage electrical wire above the ground.
An employee was retrieving a Christmas tree from a shelf using a ladder. He missed a step and fell to the concrete floor. He sustained injury to his head and wrist.
An employee was operating an agricultural tractor during sugarcane harvesting. The employee sustained a lumbar sprain due to vibration or motion from the tractor.
An employee was moving a 3-ton condensing unit, strapped down on a dolly, out of a garage. The strap broke, causing the employee to fall backward onto the brick pavered driveway. The employee suffered injury to a spinal ligament in the neck.