Struck by or caught in swinging door or gate · Amputations
At a glance
Federal OSHA recorded a severe workplace injury
at ROBERT BOSCH, 2800 S. 25TH AVE., BROADVIEW, ILLINOIS 60155
on — Amputations, affecting the fingertip(s).
Watch Robert Bosch — freeGet an email when a new federal OSHA severe-injury report for Robert Bosch is published. One employer, no account, unsubscribe in one click.
Final narrative
An employee was leaving the break room and pushed open the right-side door. Instead of exiting through the door, he turned back into the break room to throw away thrash in a trash can located immediately to the right side of the exit door. As he leaned towards the trash can, he placed his left hand on the door frame with his little finger between the door and the door jamb. When the door closed, it pinched his left little finger, resulting in a fingertip amputation (without bone loss).
AmputationFingertip(s)Doors, except garage and vehicle
An employee was doing a repair in an office building. He was closing a bank vault door when his right index finger became caught between the door and the door frame resulting in amputation of the fingertip.
An employee's left index finger was pinched between a cattle gate and a concrete wall, resulting in amputation of soft tissue and loss of the fingernail.
On December 11, 2023, an employee was transporting equipment for demolition tasks and waiting for the superintendent to open the door. The door closed and amputated the tip of the employee's left thumb.
More severe injuries in this industry (NAICS 336399)
An employee was making repairs to a milling machine located in the mold shop. While using a screwdriver to make adjustments, the machine energized and struck the employee. The employee's right arm was fractured.
An employee was breaking down dunnage to prepare totes and trays to go through a tote washer. A tow motor driver asked the employee to move a cart that was in the way so the tow motor could remove a gaylord. The employee moved the cart and then stepped away from the tow motor. As the employee moved to an area between carts, his right foot got caught by a cart, causing him to twist and fall on top of a cart, landing on the left flank of his torso. The employee suffered a hemorrhage on his left flank.
Three employees were installing a transfer rail in a press. There were two employees holding the rail and the injured employee was at the end of the rail guiding the rail into the bracket. The task was done manually with no mechanical equipment. The employee had their finger at the end of the rail and went to make sure the rail was lined up while the other two employees pushed it into the bracket, causing their finger to become pinched between the rail and bracket. The employee's middle fingertip was amputated. Protective gloves were worn at the time of the incident.
An employee was walking across the dock, interacting with forklift drivers on what was being loaded. A forklift drove forward with a tall load on the forks. The employee was struck by the load (running board/rocker panel rack) on the forklift. The employee sustained several contusions and an injury to their right Achilles tendon that required surgery.
An employee was changing a die in a press when the die slipped and crushed the employee's left index finger. The employee sustained an open facture of the tuft of the left distal phalanx and a partial amputation.
An employee was driving a boom lift (in the lowered position) in an exterior dock area. The lift s left wheels rolled onto base plates that covered a 3-foot-deep sump pit. The base plates failed, and one side of the lift dropped. The employee's left leg was caught under the lift basket, and he suffered a fracture to the lower leg including the ankle.