Newport News Shipbuilding Division of Huntington Ingalls Industries

On October 16, 2024, an employee was installing a 2-inch by 6-inch pin in the eyelets of a large machinery door's cylinder and hinge. He was using a pry bar to raise the cylinder into position and confirming the alignment of the eyelet holes with his left index and middle fingers. The pry bar shifted, which caused the cylinder to drop onto his fingers. The employee's left index fingertip was amputated.

An employee was stepping down off a temporary fixture that was about 18 inches high when they lost their balance and fractured their tibia.

An employee was touring a ship when they passed out and fell to the flight deck, resulting in a fractured ulna and fractured distal radius.

A temporary employee was using a hammer to remove loosened coupling bolts from the main shaft coupling in the shaft alley of a submarine. The hammer struck his left middle finger, causing an open fracture to the tuft of the last joint.

On December 7, 2021, a crane operator was tasked with relocating four lifting pad eyes from a pallet on the floor. The handling gear to be used was located on a handling gear rack. As the crane was hoisting a set of hook chains from the rack, the handling gear rack fell over onto a nearby employee, resulting in a fractured left femur.

An employee was installing wood trim surrounding a skylight inside a home. While holding a piece of trim in it's desired location, his pneumatic nail gun discharged, sending a 3/4-inch pin nail into his left forearm.

An employee removed a safety valve on a trailer that unknowingly contained nitrogen gas. The gas released from the trailer and pushed the employee backward off a scaffold approximately 10 feet before they struck a garage door, resulting in a pelvic injury.

An employee was sitting at her workstation when a nail gun malfunctioned and shot a nail into her left leg. She suffered a puncture and blood vessel injury and was hospitalized.

On November 25, 2023, an employee was using a high-pressured water hose to perform sewer line cleaning operations. The employee's right little finger and palm were lacerated by pressurized water from the hose.

An employee was hydroblasting when they slipped and the pressurized water stream lacerated their left ankle.

An employee was hooking up bundled tie-downs with a chain. While he was holding a hook, the other hook was unlocked. This caused the employee's hook to slide down and pinch his right index finger between the chain and the shackle. He suffered an amputation to the fingertip (without bone loss), as well as an open fracture.

An employee was struck by a plasma cutter and suffered a broken left tibia and fibula. The employee was hospitalized.

An employee was preparing to bend a flat bar in a brake press. When the machine was jogged, the stock rotated up and crushed his left middle fingertip against the outer frame of the die. The fingertip was amputated.

An employee was cutting metal with a torch. A piece of metal struck the employee's left foot, causing multiple fractures to metatarsal(s). The employee was hospitalized.

An employee was descending a ladder carrying a bag of trash. He fell, landed on the ground about 10 feet below, and suffered fractures to his right hip and pelvis.

A building engineer was inspecting a generator. As he closed the generator enclosure door, his right ring finger was caught between the door and the door frame. The fingertip was amputated.

An employee was walking back to a carrier case with mail in her hand when she tripped over a tub. Her back overarched as she fell, resulting in a fractured back that required hospitalization.

An employee was driving a utility tractor rig when it struck the rear trailer of another utility tractor rig, which was traveling in the opposite direction. The glancing impact caused damage to the cab, and he sustained a laceration on right side of his face, a cervical fracture, two fractured left ribs, and a pelvic fracture. The employee was hospitalized.

An employee was washing an aircraft from a scissor lift when they fell to the floor. The employee sustained a back injury and lacerations to their head and neck.

An employee was working with a drill and a metal cable. The drill caught the cable and caused an amputation to the employee's left ring finger.