FREER, TEXAS—
Raytheon Company
Direct exposure to electricity, unspecified · Electrical burns, unspecified
At a glance
Federal OSHA recorded a severe workplace injury at Raytheon Company, ROTHR Site, FREER, TEXAS 78357 on — Electrical burns, unspecified, affecting the upper and lower limb(s).
Final narrative
An employee was taking pictures of an electrical transfer switch when he lost his footing and slipped, making contact with a live circuit. The employee sustained abrasions on the right shoulder, and burns to the left shoulder, left leg, and both hands.
More severe injuries at Raytheon Company
MC KINNEY, TEXAS—
Raytheon Company
An employee was loading a 150-pound block of aluminum into a CNC machine when their right hand was struck by the block. The employee sustained a fracture and severed tendon to the index finger, as well as a laceration to the middle finger that required stitches.
NASHUA, NEW HAMPSHIRE—
Raytheon Company
An employee was lifting boxes when they suffered a strained back, resulting in hospitalization.
JAMAICA, NEW YORK—
Raytheon Company
An employee fell from a pickup truck while unloading equipment, suffering a fractured right wrist and left elbow.
PREMONT, TEXAS—
Raytheon Company
An employee's personal gun discharged into his left hand, injuring his index finger, which had to be surgically amputated.
MC KINNEY, TEXAS—
Raytheon Company
An employee sitting at a desk was hospitalized after being bitten by a spider.
View Raytheon Company's full OSHA safety record →
Similar incidents · Same event type
DOTHAN, ALABAMA—
Bob Woodall Air Care Systems, Inc.
An employee was installing a 15-amp breaker in an electrical panel when a 12-gauge ground wire touched the positive busbar of the panel, resulting in an arc flash. The employee sustained a second-degree burn to their left hand.
KENNEDY SPACE CENTER, FLORIDA—
Amentum Spaceport LLC
An employee was repairing an HVAC system in the drop tile ceiling of a conference room when they were shocked, causing them to fall from the ladder. The employee sustained burns to their right middle and ring fingers.
NEWELL, WEST VIRGINIA—
Marsh Bellofram Corporation
An employee was replacing a contactor inside an electrical panel attached directly to a press. The press itself was receiving power from another main panel. After replacing the contactor, the employee flipped the switch and an arc flash occurred, burning the employee's elbow, bicep, and neck.
JACKSONVILLE, FLORIDA—
Heart Utilities of Jacksonville, Inc.
An employee was attempting to switch a medium-voltage primary cable and install a 200-amp fuse barrel. The employee contacted the bottom of the switch gear cradle for the fuse barrel, causing an arc blast. The electricity entered the employee s left hand and exited his big toes, resulting in electric shock and burns to the left hand, arm, shoulder, and both feet. The employee was hospitalized.
CARRABELLE, FLORIDA—
Duke Energy Florida, LLC
On December 6, 2023, an employee of Duke Energy was working on a single-phase 120-/240-volt parallel service re-tap when a secondary flash occurred in an underground service. The employee suffered a second-degree burn to the face and was hospitalized.
More severe injuries in this industry (NAICS 334511)
LIVERPOOL, NEW YORK—
Lockheed Martin Mission Systems and Training
Two employees were removing a service lift platform from the back of a radar system. While handling the service lift platform, employee 2 was standing on the back of the radar and lost their footing, causing the service lift platform to shift and fall. The injured employee then fell from the top of the platform electronic subsystem (PES) to the floor, approximately 56 inches. The injured employee fractured his left elbow and left hip.
JACKSONVILLE, FLORIDA—
Northrop Grumman Systems Corporation
On June 27, 2025, an employee was walking out of the hangar when he tripped and fell on the concrete ramp. He sustained lacerations to his right elbow and right hand, and was hospitalized with a fractured right hip.
BATESVILLE, MISSISSIPPI—
Parker-Hannifin Corporation
An employee was performing maintenance activities on a ladder when they fell approximately 46 inches to the ground, resulting in a fracture to the left pelvis/sacrum.
MC KINNEY, TEXAS—
Raytheon Company
An employee was loading a 150-pound block of aluminum into a CNC machine when their right hand was struck by the block. The employee sustained a fracture and severed tendon to the index finger, as well as a laceration to the middle finger that required stitches.
WICHITA, KANSAS—
Lee Aerospace Plant 5
An employee picked up material out of a cardboard box that was on the floor. As he was carrying the material, he stepped backward and tripped over the cardboard box, causing him to fall and suffer a compound fracture of his leg.
More severe injuries in TEXAS
EAST BERNARD, TEXAS—
T G Meat Center LLC
After cutting a slab of beef short ribs, an employee turned to grab the pieces he had cut and his right hand contacted the saw blade. The employee sustained an amputation to his right index finger.
LUBBOCK, TEXAS—
Professional Flooring Supply
An employee was unloading a carpet pad from a truck when they fell from the truck dock to the concrete below, resulting in five fractured ribs and an injury to their left lung.
HOOKS, TEXAS—
EnviroSafe Demil LLC
An employee was inspecting flares processes. The employee received burns to the front side of the body, face and arm from the flares.
LOLITA, TEXAS—
Inteplast Group
An employee was removing plastic material from a production line when the machine cycled and amputated his left index, ring, and little fingers.
HALLETTSVILLE, TEXAS—
Regency IHS of Fairwinds Halletsville, LLC
An employee was walking up a walkway to enter a building through the back entrance when she tripped over the lip of the cement ramp. The employee fell and sustained a fractured right hip.