Struck against moving part of machinery or equipment · Amputations
At a glance
Federal OSHA recorded a severe workplace injury
at Integrated Fiber Solutions (IFS), LLC, 19 Westside Industrial Blvd. NW, ROME, GEORGIA 30165
on — Amputations, affecting the fingertip(s).
Final narrative
An employee was cutting yarn. The waste yarn cut the employee's left ring finger, amputating the tip.
AmputationFingertip(s)Spinning machinery
More severe injuries at Integrated Fiber Solutions (IFS), LLC
An employee was using an aspirator when yarn came loose, wrapped around a rotating roller, and then wrapped around the employee's left ring finger, resulting in a partial amputation.
An employee was operating a strip saw. As the employee shut off the saw, their right index and middle fingertips were amputated by the blade before it came to a complete stop.
An employee was using a table saw to cut a piece of wood for wall framing. The wood jumped, causing the employee's hand to move toward the saw, amputating their left index finger and causing a laceration on their hand.
An employee was operating a trim saw. While trying to free a jammed board she had just cut, she came into contact with the running saw blade, which amputated her right thumb.
After replacing an air cylinder, an employee was under a conveyor belt to move it back to center. His left arm was pulled into the conveyor. The employee was hospitalized with a fractured arm.
An employee was on a roof, looking for the source of a leak. A power pump sent condensate up a vent pipe, and steam and boiling water discharged onto the employee. The employee suffered burns to their back and shoulder.
On October 25, 2024, an employee was operating a warper and had just completed a full beam. He doffed the completed beam onto the floor. The empty beam, which is stored overhead, came down as the employee's left hand was guiding the completed beam. This resulted in the amputation of the little finger.
An employee was in a warehouse moving a portable generator and pinched his right middle finger between two metal hinges, resulting in amputation at the third joint.
An employee was helping to lift the grating from a floor draining system when the grating slipped and landed on his hand, resulting in the amputation of his right middle finger at the first joint.
During a workshop meeting in a hotel, an employee heard a drilling noise, so he walked outside to see what it was. An explosion occurred (possible gas line) and his face, ear, and hair were burned. He also fell and sustained a pelvic fracture.
An employee was using a tool to remove a rag from a roll on the tube mill. The roll pulled the tool and the employee's right hand into the roll, resulting in a partial amputation of the little finger and a fracture to the index finger.