Entangled in other object or equipment · Amputations
At a glance
Federal OSHA recorded a severe workplace injury
at Integrated Fiber Solutions (IFS), LLC, 2313 Dalton Industrial Court, DALTON, GEORGIA 30721
on — Amputations, affecting the finger(s), fingernail(s), unspecified.
Final narrative
An employee was using an aspirator when yarn came loose, wrapped around a rotating roller, and then wrapped around the employee's left ring finger, resulting in a partial amputation.
On November 9, 2023, an employee was removing plywood from the west face of a basement level buck hoist to prepare to dismantle one of the cabs. When the employee pulled on the plywood, it fell and pulled a rope that partially amputated the employee's thumb.
An employee was holding a rigging line and assisting in the removal of an old light pole from its base. When the load was lifted by a forklift, it shifted. The tag line lifted the employee off the ground and propelled him through the air. The employee landed on the ground and sustained back fractures.
An employee was performing maintenance on a bucket truck when his right hand became caught in some rope, causing amputations to three fingers down to the first knuckle.
An employee was conducting a fall rescue demonstration. A 165-pound demonstration dummy was released from a height, putting tension on the lanyard. The employee's left hand, little finger, and thumb were caught in the wire rope lanyard, resulting in a medical amputation of the left little finger as well as lacerations to the left thumb.
An employee was using a crank and cable to lower a light tower due to windy conditions. The light shaft became hung up and released the tension in the cable, which wrapped around the employee's left hand, resulting in amputations of three fingers.
More severe injuries in this industry (NAICS 313110)
After replacing an air cylinder, an employee was under a conveyor belt to move it back to center. His left arm was pulled into the conveyor. The employee was hospitalized with a fractured arm.
An employee was on a roof, looking for the source of a leak. A power pump sent condensate up a vent pipe, and steam and boiling water discharged onto the employee. The employee suffered burns to their back and shoulder.
On October 25, 2024, an employee was operating a warper and had just completed a full beam. He doffed the completed beam onto the floor. The empty beam, which is stored overhead, came down as the employee's left hand was guiding the completed beam. This resulted in the amputation of the little finger.
An employee was in a warehouse moving a portable generator and pinched his right middle finger between two metal hinges, resulting in amputation at the third joint.
An employee was helping to lift the grating from a floor draining system when the grating slipped and landed on his hand, resulting in the amputation of his right middle finger at the first joint.
During a workshop meeting in a hotel, an employee heard a drilling noise, so he walked outside to see what it was. An explosion occurred (possible gas line) and his face, ear, and hair were burned. He also fell and sustained a pelvic fracture.
An employee was using a tool to remove a rag from a roll on the tube mill. The roll pulled the tool and the employee's right hand into the roll, resulting in a partial amputation of the little finger and a fracture to the index finger.