MONMOUTH, ILLINOIS—
Smithfield Farmland Corp
Other fall to lower level less than 6 feet · Amputations
At a glance
Federal OSHA recorded a severe workplace injury at Smithfield Farmland Corp, 1220 North 6th Street, MONMOUTH, ILLINOIS 61462 on — Amputations, affecting the fingertip(s).
Final narrative
At about 5:20 p.m. on September 26, 2020, an employee was on a table about 2 1/2 feet high, checking for a blockage in a metal chute that deposited sirloin onto an overhead conveyor. The employee fell, and their right little finger became lodged between the chute and a metal shield used to prevent product from falling off the conveyor. The fingertip was amputated at the last joint.
More severe injuries at Smithfield Farmland Corp
MONMOUTH, ILLINOIS—
Smithfield Farmland Corp
An employee was moving a trolley to the index lifter. The index lifter actuated and crushed his right thumb, resulting in a laceration that required hospitalization and surgery.
MONMOUTH, ILLINOIS—
Smithfield Farmland, Corp.
At about 2:50 p.m. on May 20, 2020, an employee was loading broth from a holding tank into a tanker trailer in an animal feed department. As the trailer became full, the employee began to remove the load hose from the trailer connection and was sprayed by the broth, suffering burns to the right arm, the torso, and the right side of the face. The employee was hospitalized.
LINCOLN, NEBRASKA—
Smithfield Farmland Corp.
An employee was pushing a loaded cart into the oven and struck the oven. His left ring finger was pinched between the cart and a tray that had shifted after he had struck the oven causing a fingertip amputation.
MONMOUTH, ILLINOIS—
Smithfield Farmland, Corp.
An employee was lubricating a shaft on a drum machine when the drum released onto the shaft, crushing and fracturing the employee's right index finger. The employee was hospitalized and had surgery.
MONMOUTH, ILLINOIS—
Smithfield Farmland, Corp.
An employee was clearing plastic from a packaging machine when his left index and middle fingers contacted the machine and were injured. He was hospitalized and had surgery.
View Smithfield Farmland Corp's full OSHA safety record →
Similar incidents · Same event type
JACKSON, MISSOURI—
Electrical Contractors Inc.
An employee was climbing a step ladder while carrying a 3-foot piece of conduit. As he went to reposition his feet on the ladder by pivoting, he slipped and fell from the third rung of a 6-foot ladder. The employee sustained fractures to the left femur, right elbow, and right ring finger.
FORT RUCKER, ALABAMA—
M1 Support Services
An employee was descending a 4-step maintenance stand when she missed the bottom step and fell to the hangar floor. The employee suffered a left hip fracture.
PHILADELPHIA, PENNSYLVANIA—
FEDEX Ground Package System, Inc.
An employee stopped a belt and was going to check it for missing packages. She fell backward 3-4 feet from an elevated platform and sustained a broken right arm.
LAFAYETTE, COLORADO—
SRM Concrete
An employee had just finished a routine concrete pour and was ascending the ladder to clean the concrete mixer truck. The employee lost their grip and fell approximately 2-3 feet, contacting the truck's bumper. The employee suffered rib fractures and a punctured lung.
LOS ANGELES, CALIFORNIA—
U.S. Postal Service - Los Angeles P&DC
An employee was performing duties as an expeditor. After opening the dock door, the employee scanned the barcode on the door of the truck and placed one foot on the truck and one foot on the dock. The truck drove out of the stall, causing the employee to fall 4 feet off the dock onto the concrete. The employee sustained fractures to the right side of the pelvis, elbow, and a left ring fingertip as well as injuries to the right wrist and bruising to the back and stomach.
More severe injuries in this industry (NAICS 311611)
AMARILLO, TEXAS—
Tyson Fresh Meats, Inc.
An employee was scraping dried glue from the top lid of a hot glue pot. His left hand slipped and came into contact with the hot glue. He then suffered burns to his hands and fingers as he tried to remove the glue. He was hospitalized.
IDAHO FALLS, IDAHO—
Intermountain Packing, LLC
An employee was in a scissor lift approximately 20 feet above the ground to place a plastic tarp on a catwalk in order to catch condensation. They positioned the lift opposite the work area and stepped out of the scissor lift onto an I-beam. The employee fell from the I-beam to the ground. The employee was hospitalized with a skull fracture on the right side of their head and injuries to the chest and both eyes.
DODGE CITY, KANSAS—
Cargill Meat Solutions Corporation
A maintenance employee was called to look at a pallet conveyor machine where a chain had fallen off a sprocket wheel. When the employee grabbed the loose chain, a light sensor caused the machine to restart. This created a pinch point between the chain and sprocket that caught the employee's left little finger. The finger was surgically amputated at the second knuckle.
SOUDERTON, PENNSYLVANIA—
JBS Souderton, Inc.
The injured employee was standing by one of the stationary computers along the wall. There was a half-pallet located approximately 3 feet behind the employee that consisted of 12-pound boxes stacked six boxes high. A forklift was transporting a pallet that came in contact with the stationary pallet behind the injured employee, causing four boxes to fall and contact their legs. The injured employee was hospitalized with leg injuries.
CRETE, NEBRASKA—
Smithfield Foods
An employee was using a box strapping machine to place straps on boxes when his right middle finger was caught in the machine, resulting in an open fracture to the distal phalanx.
More severe injuries in ILLINOIS
ROUND LAKE, ILLINOIS—
Takeda Pharmaceuticals U.S.A., Inc.
An employee fell while moving a water canister, resulting in fractures to four fingers on her right hand.
KEWANEE, ILLINOIS—
Great Dane Ltd. Partnership
An employee was changing a die in a press when the die slipped and crushed the employee's left index finger. The employee sustained an open facture of the tuft of the left distal phalanx and a partial amputation.
FRANKLIN PARK, ILLINOIS—
Olympia Food Industries Inc.
An employee was mixing sauce using a sauce barrel mixer when his left little finger was amputated.
NORTH CHICAGO, ILLINOIS—
AbbVie Inc.
An employee was driving a boom lift (in the lowered position) in an exterior dock area. The lift s left wheels rolled onto base plates that covered a 3-foot-deep sump pit. The base plates failed, and one side of the lift dropped. The employee's left leg was caught under the lift basket, and he suffered a fracture to the lower leg including the ankle.
MONTGOMERY, ILLINOIS—
TSA Processing - Montgomery
A temporary employee was carrying a nail gun through the warehouse when it hit his leg, activated, and fired a nail into the leg.