CHIPPEWA FALLS, WISCONSIN—
Berry Global Inc.
Fall on same level, n.e.c. · Intracranial injuries, unspecified
At a glance
Federal OSHA recorded a severe workplace injury at Berry Global Inc., 1701 1st Avenue, CHIPPEWA FALLS, WISCONSIN 54729 on — Intracranial injuries, unspecified, affecting the brain.
Final narrative
On October 5, 2020, at approximately 8:13 a.m., an employee was preparing to string a cast extrusion line. When the employee ducked under the winder to grab the rope used to string, the carriage moved forward and struck the employee in the face. The employee fell to the floor and struck their head on the floor resulting in a severe head injury.
More severe injuries at Berry Global Inc.
MONROE, LOUISIANA—
Berry Global Inc.
An employee was operating a recycling mixer machine when his left arm was caught in the auger resulting in amputation of the arm.
MONROEVILLE, OHIO—
Berry Global, Inc.
On September 20, 2022, an employee was installing wear pads under the newly installed mold carrier in a plastic injection press carrier. The employee used a crane with a nylon sling to slightly tilt the carrier so the wear pads could be placed. The sling failed, snapped, and struck the employee's left index finger, causing an amputation to the finger.
HOT SPRINGS, ARKANSAS—
Berry Global, Inc.
An employee went to pick up a tool that had fallen near an adjacent machine. Their left hand became caught inside a blower motor fan blade, resulting in a dislocated finger and a fractured finger. Surgery was required to repair the injuries.
TULSA, OKLAHOMA—
Berry Global, Inc.
An employee was trying to pull trim on rollers. His left wrist and fingers were pinched by the edge rollers, causing fractures to the wrist, the little finger, and the ring finger.
ALSIP, ILLINOIS—
Berry Global, Inc.
At 4:10 a.m. on April 10, 2020, an employee was setting up a new roll of plastic on a winder machine. The machine pulled in the employee's left hand, breaking several bones in the forearm area. The employee was hospitalized.
View Berry Global Inc.'s full OSHA safety record →
Similar incidents · Same event type
ATTLEBORO, MASSACHUSETTS—
Abbott-Action, Inc.
An employee was pulling on a bale of corrugated cardboard boxes that were on a conveyor. The straps on the bale failed and the employee fell to the floor. The employee was hospitalized and required surgery for a fractured femur and/or hip.
CHARDON, OHIO—
United States Postal Service
On December 27, 2023, an employee was delivering mail to an apartment complex when their knee gave out and they fell to the ground. The employee was hospitalized with a left tibia fracture.
SUWANEE, GEORGIA—
Millennium Mat Company
An employee was walking to the inventory cage when her ankle gave out and she fell to the floor. The employee sustained a femur fracture and was hospitalized.
MIAMI, FLORIDA—
Publix Super Markets, Inc.
An employee was dislodging a pallet that was stuck when boxes of product fell onto them, causing them to fall to the ground. The employee suffered a fractured femur.
NORFOLK, VIRGINIA—
Navy Gateway Inn & Suites Front Desk
An employee was exiting an elevator when he lost balance and fell to the floor, resulting in a fractured hip.
More severe injuries in this industry (NAICS 326112)
LOLITA, TEXAS—
Inteplast Group
An employee was removing plastic material from a production line when the machine cycled and amputated his left index, ring, and little fingers.
OAKWOOD, GEORGIA—
Primex Plastics Corporation
An employee was using straps to secure a load inside a transport trailer. The employee was standing on a stack of finished goods that was three pallets high. Each pallet was 16 inches high. He was walking from the stack of three pallets onto a stack of two pallets when he lost his balance and fell onto another stack of finished goods (that was two pallets high) and then landed on the floor of the trailer. The employee was hospitalized with fractured ribs.
WICHITA FALLS, TEXAS—
Sealed Air
An employee was unclogging a resin sifting machine. The rotary sifter's automatic system activated and the sifter blade struck the employee's fingertip, causing an avulsion. The fingertip was medically amputated.
JACKSONVILLE, FLORIDA—
Sigma Extruding Corp.
An employee was helping to remove a roll of plastic from a line when the tail stock on the machine snapped back and caught the employee's right middle fingertip, resulting in a partial amputation.
KANSAS CITY, MISSOURI—
MULTIVAC
An employee was investigating a possible issue with a piece of equipment when the equipment started and amputated his left index fingertip.
More severe injuries in WISCONSIN
MADISON, WISCONSIN—
RG Professional Carpenter, Inc.
The injured employee was assisting five other employees with bracing a wall panel that was being stood up. Another employee slipped on frost on the floor surface. The employees went to evacuate the area in anticipation of the wall panel falling over. The injured employee went to jump through a window opening within the wall panel and their lower half was crushed by the falling wall panel. The employee sustained a fractured pelvis.
FRANKLIN, WISCONSIN—
General Thermodynamics, Inc.
An employee was using a vertical band saw to cut a thick piece of rubber material. While being cut, the material shifted, causing the employee s right hand to contact the moving blade. The employee's thumb was amputated below the knuckle. The employee was hospitalized, undergoing surgery.
SAINT CLOUD, WISCONSIN—
Sargento Foods Inc
A production sanitation employee was pre-rinsing an incline conveyor and noticed cheese stuck between the belt idler. The employee went to remove the cheese and their glove got caught and pulled their left forearm into the conveyor. The employee's arm was fractured. The machine was not locked out/tagged out at the time.
HIXTON, WISCONSIN—
Asher Enterprises, Inc.
An employee was on a ladder, taking measurements for a new gutter installation. The ladder slipped out from under him and both he and the ladder fell to the ground. He was hospitalized with seven broken ribs and a broken clavicle.
VERONA, WISCONSIN—
Consolidated Electrical Distributors Inc.
An employee was unloading a truck for a delivery job. While moving boxes in the truck, the employee tripped over a pallet and fell out of the truck to the ground, resulting in four broken ribs.