ROUND ROCK, TEXAS—
Cargill Inc.
Fall on same level due to slipping · Fractures
At a glance
Federal OSHA recorded a severe workplace injury at Cargill Inc., 101 South Chisolm Trail Drive, ROUND ROCK, TEXAS 78681 on — Fractures, affecting the thigh(s).
Final narrative
An employee had just finished loading meat onto a conveyor belt. While walking in her work area, she slipped and fell on a mixture of oil and water. The employee broke her upper left femur requiring hospitalization and surgery.
More severe injuries at Cargill Inc.
ROUND ROCK, TEXAS—
Cargill Inc.
An employee was conducting preventive maintenance on a decline conveyor, spraying lubricant on its tension rollers, when his left arm was caught by the conveyor system and pulled between the roller and the belt. He suffered a fracture to the wrist and two fractures to the forearm.
BLAIR, NEBRASKA—
Cargill Inc.
An employee was bringing a filter online. When the employee opened a valve to initiate flow through the filter, the gasket on the filter housing failed, spraying a water/erythritol mixture (heated to about 175 degrees Fahrenheit) toward the employee. The employee moved back quickly and their chemical suit caught on something, causing it to open. The mixture burned the employee's abdomen and left arm.
SPRINGDALE, ARKANSAS—
Cargill, Inc.
An employee was replacing the exhaust fan above the scalding area when their finger became pinched in the exhaust fan shroud. The employee sustained amputation of the distal tuft of their right middle finger with bone loss.
FORT MORGAN, COLORADO—
Cargill, Inc
On July 17, 2024, an employee was trying to retrieve his knife from the bottom of a sterilizer. Water in the sterilizer, heated to 180 degrees, entered the employee's right glove and burned his palm and the top of his hand. He was hospitalized.
SALINA, KANSAS—
Cargill, Inc.
An employee was waiting for the elevator to get to the floor that he worked on. The employee went to step through the elevator door, but the elevator lift was not there, causing him to fall 20 feet to the basement below. The employee sustained fractures in both legs, the right heel, and lower vertebrae. He was hospitalized.
View Cargill Inc.'s full OSHA safety record →
Similar incidents · Same event type
EARTH CITY, MISSOURI—
AT & T
An employee was stepping out of a car when they slipped and fell on ice, resulting in a femur fracture.
NORMAN, OKLAHOMA—
REYNOLDS FORD NORMAN
An employee was closing up for the weekend when they slipped on oil and brake fluid and fell. The employee suffered a leg fracture.
WEST BLOCTON, ALABAMA—
The Westervelt Company
An employee was working in the forest flagging an area to be harvested. He took a step and his foot slipped on a stick hidden under the leaves, causing him to fall to the ground. He landed on his right foot/lower leg resulting in a fractured tibia.
MARION, OHIO—
The Wyndmoor of Marion (OH), LLC
An employee was inspecting an apartment to ensure it was ready for a new resident to move in. The carpet in the apartment had been recently cleaned and was still wet. As the employee went from the carpet to the tiled floor of the bathroom, they slipped and fell, resulting in a torn left hamstring.
SUTHERLAND, NEBRASKA—
U.S. Postal Service
An employee was delivering a letter along a rural carrier route when she stepped on an ice-covered snow drift, slipped, and fell to the ground. The employee sustained a right hip fracture that required surgery.
More severe injuries in this industry (NAICS 311612)
EAST BERNARD, TEXAS—
T G Meat Center LLC
After cutting a slab of beef short ribs, an employee turned to grab the pieces he had cut and his right hand contacted the saw blade. The employee sustained an amputation to his right index finger.
MANITOWOC, WISCONSIN—
Lakeside Foods
An employee was using a de-clipping machine to cut the metal clips off of sausage sticks. As the employee put a link of sausages into the machine, their hand slipped into the point of operation. A piston pinched the employee's left index finger, causing a partial amputation.
ST CHARLES, ILLINOIS—
Smithfield Packaged Meats Corporation
An employee was operating a small tabletop grinder in a food safety quality assurance lab. She was stuffing meat down the grinder's chute when the grinder caught her right hand. Its auger caused an amputation to her middle finger and a partial amputation to her index finger.
SHEBOYGAN FALLS, WISCONSIN—
Johnsonville, LLC
An employee was cleaning a part on a pedestal grinder. The employee's middle finger contacted the abrasive wheel, resulting in a partial amputation.
FORT MORGAN, COLORADO—
Cargill, Incorporated
A maintenance employee was removing an inspection plate from an industrial cooker. Hot liquid spilled onto him and burned his hands, arms, and torso area. He was hospitalized.
More severe injuries in TEXAS
EAST BERNARD, TEXAS—
T G Meat Center LLC
After cutting a slab of beef short ribs, an employee turned to grab the pieces he had cut and his right hand contacted the saw blade. The employee sustained an amputation to his right index finger.
LUBBOCK, TEXAS—
Professional Flooring Supply
An employee was unloading a carpet pad from a truck when they fell from the truck dock to the concrete below, resulting in five fractured ribs and an injury to their left lung.
HOOKS, TEXAS—
EnviroSafe Demil LLC
An employee was inspecting flares processes. The employee received burns to the front side of the body, face and arm from the flares.
LOLITA, TEXAS—
Inteplast Group
An employee was removing plastic material from a production line when the machine cycled and amputated his left index, ring, and little fingers.
HALLETTSVILLE, TEXAS—
Regency IHS of Fairwinds Halletsville, LLC
An employee was walking up a walkway to enter a building through the back entrance when she tripped over the lip of the cement ramp. The employee fell and sustained a fractured right hip.