Ecolab Inc.

An employee was removing bees while standing 6-7 feet up on a telescoping ladder when the ladder slipped and they fell to the concrete pavers below. The employee was hospitalized with an open fracture to the left elbow that required surgery.

On August 29, 2024, at approximately 1:00 a.m., an employee was cleaning out the air pump and hoses that were used for a chemical solution. The air pump was on while boil-out chemicals (hot water with caustic chemicals) were in the tank. As the employee turned to close the drain valve on the tank, the hose disconnected from the pump and sprayed the employee with the boil-out liquid. The employee received second-degree burns to their left hand, their left leg (from knee to ankle), and the back of their right leg. They were hospitalized to treat the burns.

An employee parked his work vehicle in a customer's parking lot when a robber approached the employee with a gun and asked for his money and wallet. The robber started shooting; the employee sustained gunshot wounds to the neck and hand.

An employee was changing out a pump in a waste water treatment plant. The pump was pressurized and when he disconnected the hose, it sprayed peracetic acid in the employee's face, resulting in chemical burns.

An employee was helping to seal a grain storage bunker to prepare for fumigation. He was using a battery powered nail gun to fasten plastic sheeting on the side of the bunker when the nail gun misfired and a nail struck the employee in the left side of the chest, resulting in a puncture wound.

An employee was moving a scissor lift through a doorway. The employee was pinned between the scissor lift and the doorframe, sustained a back injury, and was hospitalized.

A concrete batch plant operator was assisting with clearing spoil piles using a skid steer. The skid steer backed into a stationary screen plant. The employee's left little finger was crushed between the controls of the skid steer and the screen plant, resulting in a fracture and laceration. The employee's finger was surgically amputated.

An employee was inspecting the overhead area of a single-person lift and repositioning the lift through a double doorway. As they were transitioning through the doorway, they were caught between the doorframe and the vertical mast of the lift. The employee was hospitalized with injuries to the nose, left maxillary sinus, left orbital bone, and left jaw, with fractures at the maxillary sinus area.

An employee was operating a roller and paving a small pathway next to a pavilion. The ground was on a slight pitch, causing him to reach up toward the roll cage to stabilize himself. His right fifth finger was pinched between the roll cage and the rafter of the pavilion. The employee sustained a partial degloving injury with partial traumatic amputation.

An employee was operating a stand-up forklift. The forklift drove into a rack in a warehouse, and the employee's right hand was caught between the rack and an upright supporting the forklift's overhead guard. The employee suffered a fracture and laceration to the hand, just below the little finger.

An employee was using an electric pallet jack to retrieve a chemical tote from a staging lane. He inserted the pallet jack under the tote and began to back up. After moving backward for approximately 15 feet, the employee tripped on a collapsible tote. As he fell, the pallet jack ran over his left foot. His ankle was lacerated and his foot was fractured.

An employee was installing network infrastructure at a client's distribution center. He was transporting a box measuring approximately 23 inches by 12 inches to a truck yard and walking along a narrow path adjacent to a trench that measured approximately 5.5 to 6 feet deep, 10 to 12 feet long, and 18 to 24 inches wide. Gravel on the path shifted beneath the employee's foot, causing him to lose balance and fall into the trench. He landed on his left side and struck a 4-inch PVC conduit pipe located at the bottom of the trench. The employee was hospitalized with fractures to his fourth, fifth, and sixth ribs on the left side.

An employee mixed sodium hydroxide pellets into a 55-gallon drum of hot water. A chemical reaction occurred and mixture splashed out of the drum, causing burns to the employee's face and neck. Personal protective equipment was not in place at the time.

An employee was cleaning a centrifugal pump. As he was cleaning a nozzle, his hand was caught in the inlet of the pump. He suffered a partial fingertip amputation.

A line leader was crouched down observing the chain and sprocket on a carpet filling machine for maintenance or repair when another employee got his right index finger caught between the chain and sprocket. Skin and the fingernail were removed and the employee required surgical amputation of the fingertip to the first knuckle.

An employee fell while moving a water canister, resulting in fractures to four fingers on her right hand.

An employee was changing a die in a press when the die slipped and crushed the employee's left index finger. The employee sustained an open facture of the tuft of the left distal phalanx and a partial amputation.

An employee was mixing sauce using a sauce barrel mixer when his left little finger was amputated.

An employee was driving a boom lift (in the lowered position) in an exterior dock area. The lift s left wheels rolled onto base plates that covered a 3-foot-deep sump pit. The base plates failed, and one side of the lift dropped. The employee's left leg was caught under the lift basket, and he suffered a fracture to the lower leg including the ankle.

A temporary employee was carrying a nail gun through the warehouse when it hit his leg, activated, and fired a nail into the leg.