Federal OSHA recorded a severe workplace injury
at Sealed Air Corporation, 1301 W. Magnolia Ave., IOWA PARK, TEXAS 76367
on — Amputations, avulsions, enucleations unspecified, affecting the Finger or thumb tip(s), nail(s).
Watch Sealed Air Corporation — freeGet an email when a new federal OSHA severe-injury report for Sealed Air Corporation is published. One employer, no account, unsubscribe in one click.
Final narrative
On August 31, 2024, at approximately 12:10 AM, an employee was correcting an alignment issue with a stack of pallets that were loaded in the pallet dispenser. His left index fingertip was pinched between the pallet support plates (flapper) and the flapper stop. The employee sustained a fingertip amputation.
Amputation Finger or thumb tip(s), nail(s) Material handling and warehousing machinery unspecified
An employee was doing quality control when they stepped back and tripped over a portable roll pusher and fell to the ground, resulting in a broken ankle that required surgery.
An employee was threading paper into the padded bag line machine. When the paper passed through the notcher section, the employee attempted to support the paper with his hand. The notcher fired and amputated his right ring fingertip. The notcher was not turned off at the time of the incident.
A crew was installing drilled micropiles alongside an outdoor covered deck foundation. The injured employee was working the front of the drill when a loose section of casing dropped onto the tip of a rig wrench and pulled the wrench down to an embedded casing. The employee's left little finger was caught between the rig wrench and the embedded casing and was amputated above the top knuckle.
An employee was checking a pole-type transformer tank for leaks. A hydraulic clamping device was lowered onto his right thumb and crushed it against the sharp edge of the bottom of the tank. He suffered a partial transphalangeal amputation to the thumb.
An employee had been cleaning the work area. While lifting a saw, the employee's index finger was lacerated by the saw blade. A tendon was cut and required surgery.
An employee was installing a hydraulic extension cylinder in a tow truck when their leg was caught between the cylinder and the truck frame. The employee was hospitalized with a broken tibia, which required surgery.
An employee was sorting sucker rods. His right hand was caught in the area where the rod hits up against the frame and his index fingertip was amputated just below the nail.
More severe injuries in this industry (NAICS 322220)
An employee was working to clean a glue roller with a scraper tool. The tool and the employee's left thumb were pinched between two rollers, resulting in a partial amputation.
An employee was shadowing coworkers while in training on the wide extrusion line. The employee went to clean the roller with a rag and cleaner when his right index finger got caught between a powered roller and a rubber roller. The employee sustained an amputation to a finger.
While operating a machine, an employee noticed that a piece of plastic material was stuck to a chrome roll. The employee was removing the plastic when their arm came into contact with the rollers. The employee suffered a contusion to the upper arm between the elbow and the shoulder.
On June 9, 2025, a machine operator was using a sorting machine to sort/clean plastic sheets. While she was freeing stuck sheets on the lift table, the table engaged and crushed her against the top railing, trapping her torso. The employee was hospitalized with contusions to her back.
After cutting a slab of beef short ribs, an employee turned to grab the pieces he had cut and his right hand contacted the saw blade. The employee sustained an amputation to his right index finger.
An employee was unloading a carpet pad from a truck when they fell from the truck dock to the concrete below, resulting in five fractured ribs and an injury to their left lung.
An employee was walking up a walkway to enter a building through the back entrance when she tripped over the lip of the cement ramp. The employee fell and sustained a fractured right hip.