PECOS, TEXAS—
NexTier Completion Solution
Contact with hot objects or substances · Thermal burns degree unspecified
At a glance
Federal OSHA recorded a severe workplace injury at NexTier Completion Solution, CON 50 T8 Sec 18 PAD 1, PECOS, TEXAS 79772 on — Thermal burns degree unspecified, affecting the Hand(s) and arm(s) n.e.c..
Final narrative
On October 24, 2024, at 1:06 AM, an employee shut the hydraulic fracturing pump's engine off and removed one of the pump's engine block coolant temperature sensors. Heated engine coolant then released from behind the sensor and burned the employee's hands and forearms.
More severe injuries at NexTier Completion Solution
POWHATAN, LOUISIANA—
NexTier Completion Solution
During fluid end maintenance, an employee was sliding the seat puller (a hand tool), which was positioned on top of the fluid end, from hole 1 to hole 2. The seat puller fell into hole 2. At the time, the employee s right hand was resting on the fluid end, and their right middle fingertip was pinched between the fluid end and the seat puller. The employee's fingertip was partially amputated.
MARSHALL, TEXAS—
NexTier Completion Solution
An employee was standing at his toolbox and retrieving tools when he was struck by a falling frac pump panel and platform ladder. The equipment knocked the employee to the ground and his neck and back were fractured.
View NexTier Completion Solution's full OSHA safety record →
Similar incidents · Same event type
NEW YORK, NEW YORK—
Spudrock LLC
An employee pulled out a bucket of hot oil from under the fryer. The employee then stood on the table to clean the back wall. He stepped down into the bucket of hot oil, resulting in third-degree burns to his left leg.
AKRON, OHIO—
Ajinomoto Health and Nutrition North America Inc.
An employee was performing maintenance under a kettle. When he removed a tri-clamp on a transfer line, the hot fat and broth material in the kettle poured out onto his arm. The employee was hospitalized with burns.
JACKSON, ALABAMA—
APAC-Alabama, Inc.
After completing a run with an oil distributor truck, an employee was working to return (suction) the hot oil to the tank of the truck. When the employee opened one of the valves, hot oil (approximately 385 degrees) sprayed their face, resulting in first-, second-, and third-degree burns.
KEARNEY, NEBRASKA—
Cellar Crew LLC
An employee was filtering a fryer with a fryer filter machine. After going around the corner and then returning to the fryers, the employee stepped into the filter machine. The hot oil burned the employee's right ankle, and the employee was hospitalized.
HAVANA, FLORIDA—
Boise Cascade Wood Products, LLC
An employee was using a water hose to clean debris out of the outfeed of a log conditioning vat. Water began entering the vat from the adjoining vat through a void in the separation wall at the infeed of the vats. As the employee was exiting the vat he had been working in using the access opening at the outfeed, hot water exiting the access opening entered the top of his protective hip wader. It pooled at the bottom of the wader and burned his left foot and ankle.
More severe injuries in this industry (NAICS 213112)
KARNES CITY, TEXAS—
3S Services, LLC
An employee had been cleaning the work area. While lifting a saw, the employee's index finger was lacerated by the saw blade. A tendon was cut and required surgery.
WEST WAREHAM, MASSACHUSETTS—
Roby's Propane Gas
An employee was delivering home heating fuel when bees came from the ground and stung the employee's face, neck, torso, and hands. The employee proceeded to shut off the oil flow before losing consciousness. They were hospitalized due to an anaphylactic reaction.
KANE, PENNSYLVANIA—
Myers Trucking, Inc.
An employee was using a torch to loosen a bolt on a water trailer. Natural gas was present in the water and it ignited, causing a fire. The employee sustained third-degree burns to their upper leg.
BROUSSARD, LOUISIANA—
Weatherford U.S., L.P.
An employee had been conducting crane operations. The employee went to stop a piece of oil and gas equipment for tubular running from falling over to the ground. Their right hand was caught between a rolling ladder and the equipment, resulting in fractures to the index and middle fingers. They were hospitalized and the middle finger required surgery.
PAWNEE, TEXAS—
Helmerich & Payne IDC Inc
An employee was working to install a drive belt on a water pump. He was holding the belt on both sides of the pulley, working to route it over the top. As he pulled down with his right hand, the pulley rotated and the belt slid over it, pulling his left little finger between the pulley and the belt. He suffered an amputation to the fingertip as well as a fracture to the ring finger.
More severe injuries in TEXAS
EAST BERNARD, TEXAS—
T G Meat Center LLC
After cutting a slab of beef short ribs, an employee turned to grab the pieces he had cut and his right hand contacted the saw blade. The employee sustained an amputation to his right index finger.
LUBBOCK, TEXAS—
Professional Flooring Supply
An employee was unloading a carpet pad from a truck when they fell from the truck dock to the concrete below, resulting in five fractured ribs and an injury to their left lung.
HOOKS, TEXAS—
EnviroSafe Demil LLC
An employee was inspecting flares processes. The employee received burns to the front side of the body, face and arm from the flares.
LOLITA, TEXAS—
Inteplast Group
An employee was removing plastic material from a production line when the machine cycled and amputated his left index, ring, and little fingers.
HALLETTSVILLE, TEXAS—
Regency IHS of Fairwinds Halletsville, LLC
An employee was walking up a walkway to enter a building through the back entrance when she tripped over the lip of the cement ramp. The employee fell and sustained a fractured right hip.