ALBERTVILLE, ALABAMA—
Mueller Co. LLC
Contact incidents unspecified · Amputations, avulsions, enucleations unspecified
At a glance
Federal OSHA recorded a severe workplace injury at Mueller Co. LLC, 956 Industrial Blvd, ALBERTVILLE, ALABAMA 35950 on — Amputations, avulsions, enucleations unspecified, affecting the Finger or thumb tip(s), nail(s).
Final narrative
On November 25, 2024, an assembly line employee was preparing to hoist a fully assembled cast iron fire hydrant using a C-clamp hoist. Their left index fingertip became caught between the hook and the eye ring resulting in amputation of the fingertip.
More severe injuries at Mueller Co. LLC
DECATUR, ILLINOIS—
Mueller Co. LLC
An employee was using a vacuum to clean chips around the table of a drill press when their gloved left hand was caught in the drill bit, resulting in amputations to the index, middle, and ring fingertips.
ALBERTVILLE, ALABAMA—
Mueller Co. LLC
An employee was loading hydrants onto a paint line bed using hoists and clamps. A hydrant slipped and their fingertip was pinched between the hydrant and clamp, resulting in a fingertip amputation.
ALBERTVILLE, ALABAMA—
Mueller Co. LLC
An employee was using an impact gun to remove a nut from a pneumatic cylinder during the disassembly of a test cell. When the gun made contact with the nut, residual pneumatic pressure caused the cylinder to release. The employee's left hand was pinned between a rod end of the cylinder and the rod end plate. The employee was hospitalized and had surgery for a hematoma.
ALBERTVILLE, ALABAMA—
Mueller Co. LLC
An employee was using a bar to remove casting debris from a rotary screen. The bar contacted the rotating portion of the screen and bent, and the employee's right hand was pushed against the machine, resulting in a compound fracture. The employee was hospitalized and had surgery.
DECATUR, ILLINOIS—
MUELLER Co. LLC
On August 8, 2022, an employee was making 1-inch valves on a machine when his left little finger was caught in a pinch point resulting in amputation of the fingertip.
View Mueller Co. LLC's full OSHA safety record →
Similar incidents · Same event type
SOUTH PORTLAND, MAINE—
HB Fleming, Inc.
A crew was installing drilled micropiles alongside an outdoor covered deck foundation. The injured employee was working the front of the drill when a loose section of casing dropped onto the tip of a rig wrench and pulled the wrench down to an embedded casing. The employee's left little finger was caught between the rig wrench and the embedded casing and was amputated above the top knuckle.
LAUREL, MISSISSIPPI—
Howard Industries Inc.
An employee was checking a pole-type transformer tank for leaks. A hydraulic clamping device was lowered onto his right thumb and crushed it against the sharp edge of the bottom of the tank. He suffered a partial transphalangeal amputation to the thumb.
KARNES CITY, TEXAS—
3S Services, LLC
An employee had been cleaning the work area. While lifting a saw, the employee's index finger was lacerated by the saw blade. A tendon was cut and required surgery.
COLUMBUS, OHIO—
Broad & James, Inc.
An employee was installing a hydraulic extension cylinder in a tow truck when their leg was caught between the cylinder and the truck frame. The employee was hospitalized with a broken tibia, which required surgery.
MIDLAND, TEXAS—
TRC Services of Texas INC
An employee was sorting sucker rods. His right hand was caught in the area where the rod hits up against the frame and his index fingertip was amputated just below the nail.
More severe injuries in this industry (NAICS 332919)
AUGUSTA, ARKANSAS—
SLOAN VALVE COMPANY
An employee was troubleshooting a shell core machine that had failed to raise the sand hopper into place for core making. The employee went to manipulate a switch and the machine cycled. The employee s left middle fingertip was caught between the roller-ball switch and the roller-ball switch target, resulting in a laceration that required surgical amputation to part of the distal phalanx.
BOWLING GREEN, OHIO—
Rosenboom Machine & Tool Inc.
On August 18, 2025, at approximately 7:40 AM, an employee utilized a pocket knife to cut banding on a new bundle of rod material. The knife blade bent during use. The employee was working to straighten the blade on a hard surface when the knife slipped, causing a lacerating their right wrist/forearm. The employee was hospitalized.
COLUMBIA, PENNSYLVANIA—
ASC Engineered Solutions
An employee was manually pulling drive belts to rotate a machine that needed repair. The employee's right index finger was pinched between a rubber drive belt and a pulley, causing an amputation to the fingertip.
RISINGSUN, OHIO—
Ashland Water Group Inc.
At about 9:15 a.m. on May 14, 2025, an employee was using a bending press to bend metal into a U shape. The press caused an amputation to the employee's left middle finger.
ODESSA, TEXAS—
Victaulic Company of America
An employee was running a test pipe for 12 feet and went to pull the pipe out of a roll grooving tool. As he was doing this, the tool's control pedal actuated, causing the tool to rotate. The employee's glove became caught and was pulled into the rollset, amputating about half an inch of his index finger.
More severe injuries in ALABAMA
GENEVA, ALABAMA—
Sysco Gulf Coast, LLC
An employee was traveling down the maintenance aisle of a warehouse on a single-pallet front rider jack. The jack malfunctioned, causing the brakes to apply; the employee fell forward onto the concrete warehouse floor. The employee suffered an injury to the left leg and was hospitalized, requiring surgery.
BESSEMER, ALABAMA—
Norflex, Inc.
An employee was operating a metal roller machine to roll a small piece of metal. The employee's right index finger became caught between the metal and the machine, and the fingertip was amputated.
ANNISTON, ALABAMA—
Ampler Pizza II LLC
An employee was shot in the leg with a pistol during an altercation with two people who had entered the store without permission.
ATMORE, ALABAMA—
Birdsong Corporation
An employee was directing a truck driver to a dump site when the truck's peanut trailer slipped off the kingpin. As the trailer fell, a ladder attached to it lacerated the employee's ear. The employee was hospitalized.
ROGERSVILLE, ALABAMA—
Pilgrims
An employee was unloading a forklift from a trailer to the ground. The employee was climbing down the ladder of the trailer when their foot slipped through one of the rungs, causing them to fall backward onto the forklift forks. The employee was hospitalized for fractured ribs.