Fall to lower level resulting from exposure or contact unspecified · Severe wounds, internal injuries and electrocution, electric shock
At a glance
Federal OSHA recorded a severe workplace injury
at CR Solar LLC dba eEquals, 1490 Sterling Rd, AMBOY, ILLINOIS 61310
on — Severe wounds, internal injuries and electrocution, electric shock, affecting the Body systems and other part(s) of body.
Final narrative
An employee was on a ladder while attaching insulated lugs to wires outside of a customer's home. The employee was electrocuted and his body locked up, causing him to fall off the ladder onto the ground feet first. The employee suffered electrocution injuries and shattered both ankles.
Hospitalized Body systems and other part(s) of body Portable ladders and stairs unspecified
An employee was troubleshooting the control setup for a variable air volume box above a ceiling. The employee's hand came into contact with an exposed, energized 277-volt wire that had loosened from its terminal on the box's assembly. He was shocked and fell off a ladder. His left hand passed across the ceiling grid and was lacerated. He also suffered an electrical burn to the right hand and was hospitalized.
An employee was working as a fire watch. The employee was exposed to anhydrous ammonia and was not able to see while climbing down a ladder due to eye irritation. The employee fell and was hospitalized for a broken ankle.
An employee was working from a ladder and adjusting a spreader guide roller with a T-handle Allen wrench. The employee came into contact with an electrical junction box/wires, was shocked, and fell off the ladder to the concrete floor. He suffered a broken right-side rib, a puncture in the right lung, and an electrical shock burn to the right palm.
An employee was on a 10-foot ladder, working to insulate 24-inch piping that was 12 feet above the ground. The pipe jack/steel tube used to raise the pipe slipped, causing the steel tube to strike the employee's face. The impact caused the employee to fall off the ladder and sustain fractures to their left tibia and fibula.
An employee was on a rooftop, supervising the lifting of a 30' x 30' structure manufactured from I-beams. The employee was knocked to the ground and the suspended load settled on them. The employee sustained a head injury, loss of an eye, and fractured ribs.
More severe injuries in this industry (NAICS 221114)
An employee was standing on a step stool, removing the nuts and bolts from the frame of a solar panel that was being replaced. The employee's cheek made contact with a connector with damaged insulation. The employee was shocked, briefly lost consciousness, and fell to the ground, suffering an injury to the left shoulder.
An employee was changing fuel filters on a front-end loader. When he descended the access steps of the engine bay, he misstepped and fell approximately 3 feet to the concrete surface below. The employee sustained a fractured left hip.
An employee was walking in the warehouse when their foot was struck by the forks of an unloaded forklift that was passing by. The employee's foot was fractured.
An employee was climbing down an extension ladder from a residential roof. The ladder collapsed under his foot, and he fell backward onto the grass. He suffered a sprained neck, a fractured scapula, and fractures to his T7 and T12 vertebrae.
An employee was working to straighten a solar panel by reaching into the unguarded rotating section of the conveyor when their right thumb got caught in the conveyor, resulting in amputation of their right thumb.
An employee was changing a die in a press when the die slipped and crushed the employee's left index finger. The employee sustained an open facture of the tuft of the left distal phalanx and a partial amputation.
An employee was driving a boom lift (in the lowered position) in an exterior dock area. The lift s left wheels rolled onto base plates that covered a 3-foot-deep sump pit. The base plates failed, and one side of the lift dropped. The employee's left leg was caught under the lift basket, and he suffered a fracture to the lower leg including the ankle.