Contact with hot objects or substances · Thermal burns second degree
At a glance
Federal OSHA recorded a severe workplace injury
at Harrah's NC Casino Company, LLC, 777 Casino Drive, CHEROKEE, NORTH CAROLINA 28719
on — Thermal burns second degree, affecting the Multiple regions of the head.
Final narrative
An employee was preparing hot melted butter on a flat-top grill and placing it in small containers once it was melted. As she turned to set the container down, it slipped out of her hand and landed on the grill. Butter splashed up and hit her in the face. The employee suffered second-degree burns to her right eye and the right side of her head and face, as well as first-degree burns to her right forearm.
Hospitalized Multiple regions of the head Fats, oils, cooking greases
An employee pulled out a bucket of hot oil from under the fryer. The employee then stood on the table to clean the back wall. He stepped down into the bucket of hot oil, resulting in third-degree burns to his left leg.
An employee was performing maintenance under a kettle. When he removed a tri-clamp on a transfer line, the hot fat and broth material in the kettle poured out onto his arm. The employee was hospitalized with burns.
After completing a run with an oil distributor truck, an employee was working to return (suction) the hot oil to the tank of the truck. When the employee opened one of the valves, hot oil (approximately 385 degrees) sprayed their face, resulting in first-, second-, and third-degree burns.
An employee was filtering a fryer with a fryer filter machine. After going around the corner and then returning to the fryers, the employee stepped into the filter machine. The hot oil burned the employee's right ankle, and the employee was hospitalized.
An employee was using a water hose to clean debris out of the outfeed of a log conditioning vat. Water began entering the vat from the adjoining vat through a void in the separation wall at the infeed of the vats. As the employee was exiting the vat he had been working in using the access opening at the outfeed, hot water exiting the access opening entered the top of his protective hip wader. It pooled at the bottom of the wader and burned his left foot and ankle.
More severe injuries in this industry (NAICS 721120)
An employee was on a ladder hanging drywall. He fell from the ladder's fourth rung, striking the ladder itself as well as the carpeted floor. He suffered five or six broken ribs, a bruised lung, and pain in the left wrist, neck, and back. He was hospitalized.
An employee was cleaning an office and walking backward when they tripped over a trash bag, fell, and struck their face on the floor. The employee sustained a brain bleed.
An employee used a step ladder to get onto a metal countertop section in a kitchen to clean an area near the ceiling. When he stepped back down from the countertop and onto the step stool, he fell to the floor, striking the counter and ladder during the fall. The employee suffered fractured ribs and contusions on his left elbow and head.
An employee was rotating a card reprint machine on a dolly. The machine caught the employee's right middle fingertip and amputated about an inch of the finger.
An employee was attaching a steel angle plate weighing (approximately 200 pounds) to the end of a structural member (5,000 pounds) and was supported by dunnage. The dunnage was a crane mat (11 inches tall) with a 4x6 board on top of it and it supported five identical members. The main piece was 30.75 feet long, 37.25 feet tall, and 1 food wide. As the employee slid the piece of metal on top of the member to begin attaching it, the entire member began to tip over. The employee went to stop the main piece from tipping over and it landed on his ankle, fracturing it.
An employee pulled into the customer's driveway, parked, and exited the vehicle. He opened the sliding side door on the vehicle to retrieve a package. The customer began backing their vehicle out of their garage and it struck the employee in the back of his left leg. He was pinned him between the two vehicles, causing contusions and lacerations.
An employee was descending the back stairwell to go to lunch when he missed a step. As he fell forward, his toes hit a step which pulled his right leg behind him. He landed on the concrete stairwell landing between floors. He sustained a partial rupture of the right quadriceps tendon and an avulsion fracture involving the right patella. The employee required surgery.