HEATERS, WEST VIRGINIA—
Conway-Phillips Holding, LLC
Fall or jump curtailed by personal fall arrest system · Amputations
At a glance
Federal OSHA recorded a severe workplace injury at Conway-Phillips Holding, LLC, Weyerhaeuser, HEATERS, WEST VIRGINIA 26627 on — Amputations, affecting the finger(s), fingernail(s), n.e.c..
Watch Conway-Phillips Holding, LLC — free
Get an email when a new federal OSHA severe-injury report for Conway-Phillips Holding, LLC is published. One employer, no account, unsubscribe in one click.
Final narrative
On August 15, 2016, at approximately 11:00 a.m., an employee was constructing a storage tank. The employee was standing on grating that surrounded the tank and at a height of approximately 47 to 48 feet. Because there were no railings, the employee wore a full body harness and was tied off to the structure. While he was tightening a bolt, the ratchet slipped off and he fell from the grating. During the fall, his right arm struck the structure, amputating his right ring finger and lacerating his arm. He was hospitalized.
Similar incidents · Same event type
TEMPLE, TEXAS—
Peabody General Contractors
An employee was walking along a trench inspecting the trench box in the excavation when he tripped and fell toward the trench. As the employee was falling head-first into the trench, he attempted to get a hold of the fall protection cable. The cable then looped around his left hand and the employee fell approximately 8 feet into the trench before the fall protection engaged. The employee suffered amputations of his left index, middle, ring, and little fingers.
MOOSE, WYOMING—
National Park Service
A ranger was performing back-country patrol duties while hiking. As they were climbing a technical rock patch, a rock handhold broke, causing the employee to fall approximately 15 feet before their belay engaged. The employee contacted a rock, resulting in a fracture to the right ilium as well as a subcutaneous hematoma to the right gluteal region.
LITTLE ROCK, ARKANSAS—
Lexicon, Inc.
Employees were erecting structural steel. The injured employee was sitting on a 12" wide horizontal member and lining up an I-beam brace as it was suspended by an overhead crane. He leaned left to push the end of the brace. The end of the suspended brace swung away from him, causing him to lose balance and fall 8 feet. His personal fall arrest system arrested his fall, but he swung into a piece of duct work during the fall that resulted in a concussion.
TALLAHASSEE, FLORIDA—
Rapid Building Solutions, LLC
On September 12, 2022, an employee was on a metal roof, installing a standing seam and insulation. He lost his balance and fell toward the third floor slab, which was 10 feet from the roof. His fall protection caught him and left him suspended about 2 to 4 feet from the slab. He suffered a brain bleed and a spinal fracture in his lower back. He was hospitalized.
HOT SPRINGS, ARKANSAS—
West Tree Service, Inc.
An employee was working from a bucket lift, removing a tree in sections. He lost his balance while pushing on a section and fell. His fall protection caught him and he swung into a tree, suffering an injury that caused head, neck, and leg pain, as well as loss of consciousness while he was at the hospital.
More severe injuries in this industry (NAICS 237990)
SOUTH PORTLAND, MAINE—
HB Fleming, Inc.
A crew was installing drilled micropiles alongside an outdoor covered deck foundation. The injured employee was working the front of the drill when a loose section of casing dropped onto the tip of a rig wrench and pulled the wrench down to an embedded casing. The employee's left little finger was caught between the rig wrench and the embedded casing and was amputated above the top knuckle.
BURLINGTON, COLORADO—
Takkion OPS Management
An employee was standing on an extension ladder, using a torquing tool to remove bolts that secured blades to a rotor. When the torquing tool activated, its reaction arm came around and pinched the employee's right middle finger against a lifting eye. His fingertip was amputated.
PALM CITY, FLORIDA—
Ahtna Marine and Construction Company, LLC
Employees were securing the fuel line of an outboard motor in preparation for removing the motor from a small vessel located in the equipment yard. A gasoline-related fire occurred and one employee sustained burns to both hands and forearms.
MENOMONIE, WISCONSIN—
Michels Construction, Inc
A marine diver/construction worker was working underwater, using a hydraulic dredge to clear sediment away from the base of a dam. The dredge's suction nozzle began migrating toward him, and then pulled in his right hand and forearm. He sustained compartment syndrome in the hand and forearm.
PORT ISABEL, TEXAS—
Bechtel Energy Construction Services, Inc.
An employee was standing on a sheet of -inch by 4-foot by 8-foot plywood on top of a rebar mat, supervising his crew. As he was moving to alert the crew to an incoming overhead load, he stepped off the plywood and his left foot slipped through the rebar mat and landed on the rebar mat below. His left ankle was broken and dislocated.
More severe injuries in WEST VIRGINIA
BERKELEY SPRINGS, WEST VIRGINIA—
Caperton Furniture Works, LLC
An employee tripped over a concrete curb stop in a parking lot. The employee fell to the ground, landing on their left hip and breaking it.
PROCTOR, WEST VIRGINIA—
Certainteed Gypsum West Virginia, Inc
An employee was conducting routine maintenance on a mixer. New lid pins had been installed, and the employee was rotating by hand to ensure they had been installed correctly. The employee's left middle finger was caught between the lid and top of a pin. The momentum from the mixer continued, causing a crushing injury to the finger. The employee underwent a medical amputation from the top knuckle to the tip of the finger.
MORGANTOWN, WEST VIRGINIA—
Owens Corning
An employee was climbing down a ladder when it slipped. The employee fell, suffering a broken scapula and broken ribs. The employee was hospitalized.
BRIDGEPORT, WEST VIRGINIA—
Applied Integrated Services, LLC
An employee was climbing down a 15-foot multipurpose ladder. The employee fell about 8 feet, landing on the concrete floor and the ladder itself. The employee suffered several injuries, all on the right side: broken ribs, a broken sternum, a broken temporal bone, broken shoulder, multiple fractures to the cheekbone, and a brain bleed.
NITRO, WEST VIRGINIA—
Fedex Freight Inc.
An employee was rolling up the landing gear on his trailer when the handle began to unwind and struck his face, fracturing his jaw. The employee was hospitalized and required surgery.