Collision between a moving and standing vehicle, nonroadway · Fractures
At a glance
Federal OSHA recorded a severe workplace injury
at Schenker Logistics, Inc., 3049 Westway Drive, EDWARDSVILLE, ILLINOIS 62025
on — Fractures, affecting the ankle(s).
Final narrative
An employee was training with a trainer to operate a high reach forklift when the employee crashed into another parked fork truck, suffering a fractured ankle that required hospitalization and surgery. The employee's leg was outside of the forklift at the time of the incident.
HospitalizedAnkle(s)Forklift, order picker, platform truck-powered
An employee was riding on a powered pallet jack near a sewer drain. The pallet jack hit a dip near the sewer drain, and the employee s left foot hit a clamp truck parked in a charging station. He suffered a cut to the big toe, as well as fractures in the toe and the foot.
An employee went to step off material handling equipment to grab their jacket when the throttle of the vehicle engaged. The vehicle reversed and the employee's left foot was crushed between two material handlers, resulting in a fracture.
An employee was working at a height of approximately 20 feet and was standing outside his forklift's basket attachment. His forklift was struck by another forklift, causing the employee to fall to the warehouse floor below. The employee sustained facial injuries, broke two ribs and an arm, and also suffered a head injury. The employee was wearing a harness at the time but it was not connected to an anchor point.
On November 8, 2023, an employee was operating a stand-up pallet jack in the warehouse. As he was backing up, the pallet jack struck the basket of a parked aerial lift. His right ankle became caught between the pallet jack and the aerial lift basket resulting in a fractured ankle.
On October 26, 2023, at approximately 12:00 PM, an employee operating a four wheeler was on their way to an off-property break location. The employee stopped the four wheeler near the administrative office to allow a log truck to exit the property. The log truck backed up, and the employee's left ankle was caught between the log truck trailer and the four wheeler, resulting in a fracture and laceration.
More severe injuries in this industry (NAICS 484230)
A truck driver was preparing a hose to load a chemical tanker trailer with sulfuric acid when sulfuric acid splashed the left side of their face and neck, causing skin burns.
An employee was disconnecting steam lines from a bulk liquid trailer. He disconnected a steam line located on a vapor recovery line when hot steam blew back onto him, resulting in burns to the left side of his abdomen, as well as his left arm and leg. The employee was hospitalized.
An employee was driving a truck when it lost power. He pulled over, opened the hood, checked the engine, and opened the radiator cap. Pressure in the radiator caused hot fluid to spew over the employee, who suffered second-degree burns to the left arm, hand, and leg.
An employee was changing a die in a press when the die slipped and crushed the employee's left index finger. The employee sustained an open facture of the tuft of the left distal phalanx and a partial amputation.
An employee was driving a boom lift (in the lowered position) in an exterior dock area. The lift s left wheels rolled onto base plates that covered a 3-foot-deep sump pit. The base plates failed, and one side of the lift dropped. The employee's left leg was caught under the lift basket, and he suffered a fracture to the lower leg including the ankle.