Contact with hot objects or substances · Thermal burns second degree
At a glance
Federal OSHA recorded a severe workplace injury
at Proficient Auto Inc, I-20 & Cooper Street, ARLINGTON, TEXAS 76015
on — Thermal burns second degree, affecting the Upper and lower extremities n.e.c..
Final narrative
An employee was driving a truck when it lost power. He pulled over, opened the hood, checked the engine, and opened the radiator cap. Pressure in the radiator caused hot fluid to spew over the employee, who suffered second-degree burns to the left arm, hand, and leg.
Hospitalized Upper and lower extremities n.e.c. Antifreeze
An employee pulled out a bucket of hot oil from under the fryer. The employee then stood on the table to clean the back wall. He stepped down into the bucket of hot oil, resulting in third-degree burns to his left leg.
An employee was performing maintenance under a kettle. When he removed a tri-clamp on a transfer line, the hot fat and broth material in the kettle poured out onto his arm. The employee was hospitalized with burns.
After completing a run with an oil distributor truck, an employee was working to return (suction) the hot oil to the tank of the truck. When the employee opened one of the valves, hot oil (approximately 385 degrees) sprayed their face, resulting in first-, second-, and third-degree burns.
An employee was filtering a fryer with a fryer filter machine. After going around the corner and then returning to the fryers, the employee stepped into the filter machine. The hot oil burned the employee's right ankle, and the employee was hospitalized.
An employee was using a water hose to clean debris out of the outfeed of a log conditioning vat. Water began entering the vat from the adjoining vat through a void in the separation wall at the infeed of the vats. As the employee was exiting the vat he had been working in using the access opening at the outfeed, hot water exiting the access opening entered the top of his protective hip wader. It pooled at the bottom of the wader and burned his left foot and ankle.
More severe injuries in this industry (NAICS 484230)
A truck driver was preparing a hose to load a chemical tanker trailer with sulfuric acid when sulfuric acid splashed the left side of their face and neck, causing skin burns.
An employee was disconnecting steam lines from a bulk liquid trailer. He disconnected a steam line located on a vapor recovery line when hot steam blew back onto him, resulting in burns to the left side of his abdomen, as well as his left arm and leg. The employee was hospitalized.
An employee was delivering propane tanks. He was unloading the propane tanks off a flatbed trailer onto the ground using a crane next to where he was standing. His knee became pinned between two 500-gallon propane tanks, resulting in bruising and swelling of the right knee that required hospitalization.
After cutting a slab of beef short ribs, an employee turned to grab the pieces he had cut and his right hand contacted the saw blade. The employee sustained an amputation to his right index finger.
An employee was unloading a carpet pad from a truck when they fell from the truck dock to the concrete below, resulting in five fractured ribs and an injury to their left lung.
An employee was walking up a walkway to enter a building through the back entrance when she tripped over the lip of the cement ramp. The employee fell and sustained a fractured right hip.