NATIONAL MAINTENANCE & REPAIR, INC.

On 2/21/2019, two employees were working to repair/resurface a 120-inch, five blade, four-ton wheel propeller inside the propeller repair shop at a shipyard repair facility. The propeller was just removed from the straightening press and the employees were in the process of moving it over to a floor stand so they could weld it, grind it and apply cosmetic treatment to it. They used an under the hook hoist system to move the propeller over to the floor stand. Once in position, they attempted to place the propeller on the stand by lowering it down onto the top of the stand and then slacking the chain. However, it would not sit flush on the stand and both agreed that they needed a different stand. One employee went to get a different stand, heard a crash and saw that the propeller had started to slide off the stand with the hoist chains now tight. The second employee suffered a deep laceration/fracture to their left leg.

An employee was attempting to load a shaft onto a flatbed truck using an overhead crane. The pull chain got stuck in the hook on the chain fall. The employee reached up to free the pull chain and his right ring finger was pinched between the chain on the overhead crane and the chain fall resulting in a fingertip amputation.

An employee was using a horizontal milling machine to cut a cap for an engine when the employee's right hand was amputated.

The employee was on top of a rail car to level the grain that was deposited into the car when they fell 13-15 feet to the ground. The employee sustained a right leg fracture.

An employee was on an extension ladder installing a satellite dish on a roof when they fell approximately 12-15 feet to the ground. The employee sustained fractures.

An employee was setting a 5-foot pry bar into a precast concrete slab and stood on the end of the pry bar to move the slab into place. The pry bar slipped out causing the employee to fall backward 15.5 feet to the dirt ground. The employee was hospitalized with a broken leg.

An employee was on a step ladder to measure and mark a crane rail for modification. The employee fell approximately 12 to 15 feet to the ground, resulting in a fractured right hip.

An employee was on a trailer securing a load of logs when they fell approximately 9-12 feet to the ground. The employee sustained brain hemorrhaging and lacerations to the thigh and above the eye. The employee was hospitalized.

An employee was hooking up bundled tie-downs with a chain. While he was holding a hook, the other hook was unlocked. This caused the employee's hook to slide down and pinch his right index finger between the chain and the shackle. He suffered an amputation to the fingertip (without bone loss), as well as an open fracture.

An employee was struck by a plasma cutter and suffered a broken left tibia and fibula. The employee was hospitalized.

An employee was preparing to bend a flat bar in a brake press. When the machine was jogged, the stock rotated up and crushed his left middle fingertip against the outer frame of the die. The fingertip was amputated.

An employee was cutting metal with a torch. A piece of metal struck the employee's left foot, causing multiple fractures to metatarsal(s). The employee was hospitalized.

An employee was descending a ladder carrying a bag of trash. He fell, landed on the ground about 10 feet below, and suffered fractures to his right hip and pelvis.

An employee fell while moving a water canister, resulting in fractures to four fingers on her right hand.

An employee was changing a die in a press when the die slipped and crushed the employee's left index finger. The employee sustained an open facture of the tuft of the left distal phalanx and a partial amputation.

An employee was mixing sauce using a sauce barrel mixer when his left little finger was amputated.

An employee was driving a boom lift (in the lowered position) in an exterior dock area. The lift s left wheels rolled onto base plates that covered a 3-foot-deep sump pit. The base plates failed, and one side of the lift dropped. The employee's left leg was caught under the lift basket, and he suffered a fracture to the lower leg including the ankle.

A temporary employee was carrying a nail gun through the warehouse when it hit his leg, activated, and fired a nail into the leg.