Other fall to lower level less than 6 feet · Soreness, pain, hurt-nonspecified injury
At a glance
Federal OSHA recorded a severe workplace injury
at Eastman Chemical Company, Texas Operations, 300 Kodak Blvd., LONGVIEW, TEXAS 75602
on — Soreness, pain, hurt-nonspecified injury, affecting the neck and back.
Final narrative
An employee was preparing to climb an 8-foot scaffold ladder to install a 6-inch piping blind flange. As the employee climbed to the fourth rung of the ladder, he struck the top of his hardhat on an overhead pipe. The employee fell from the scaffold ladder approximately 4-5 feet before landing on his hip and striking his head on the ground. He sustained spine and neck injuries that required surgery.
HospitalizedNeck and backScaffolds-staging, unspecified
More severe injuries at Eastman Chemical Company, Texas Operations
An employee was making his rounds when he identified a level indication in the vessel that he was not sure was accurate. He then drained the sit glass and the material (mineral spirits polyethylene wax and ethaline gas) ignited a flash fire, burning his left palm, both forearms, and his left calf. He was hospitalized.
An employee was climbing a step ladder while carrying a 3-foot piece of conduit. As he went to reposition his feet on the ladder by pivoting, he slipped and fell from the third rung of a 6-foot ladder. The employee sustained fractures to the left femur, right elbow, and right ring finger.
An employee was descending a 4-step maintenance stand when she missed the bottom step and fell to the hangar floor. The employee suffered a left hip fracture.
An employee stopped a belt and was going to check it for missing packages. She fell backward 3-4 feet from an elevated platform and sustained a broken right arm.
An employee had just finished a routine concrete pour and was ascending the ladder to clean the concrete mixer truck. The employee lost their grip and fell approximately 2-3 feet, contacting the truck's bumper. The employee suffered rib fractures and a punctured lung.
An employee was performing duties as an expeditor. After opening the dock door, the employee scanned the barcode on the door of the truck and placed one foot on the truck and one foot on the dock. The truck drove out of the stall, causing the employee to fall 4 feet off the dock onto the concrete. The employee sustained fractures to the right side of the pelvis, elbow, and a left ring fingertip as well as injuries to the right wrist and bruising to the back and stomach.
More severe injuries in this industry (NAICS 325188)
An employee was climbing into the cab of a semi-tractor when he stepped on the battery cover and it shifted from under him, causing him to fall to the ground. The employee sustained a fractured left wrist.
An employee was clearing a product flow restriction when the rotating valve activated. They sustained amputations to their left middle and index fingers.
A panel was being lifted when an attached roller (approximately 20 pounds) slipped and fell about 2 feet onto the hard hat of an employee working below. The roller also struck the employee's shoulder and back. The employee was hospitalized and suffered a contusion to the shoulder/back.
An employee drank water from a water cooler in the control room that was contaminated with sodium nitrite. The employee sustained methemoglobinemia and was hospitalized.
An employee was collecting waste material and taking it to a waste container that was in close proximity to material that was emitting chemical fumes due to elevated temperatures. The employee inhaled the fumes and was admitted to the hospital due to the exposure.
After cutting a slab of beef short ribs, an employee turned to grab the pieces he had cut and his right hand contacted the saw blade. The employee sustained an amputation to his right index finger.
An employee was unloading a carpet pad from a truck when they fell from the truck dock to the concrete below, resulting in five fractured ribs and an injury to their left lung.
An employee was walking up a walkway to enter a building through the back entrance when she tripped over the lip of the cement ramp. The employee fell and sustained a fractured right hip.