Direct exposure to electricity, greater than 220 volts · Electrical burns, unspecified
At a glance
Federal OSHA recorded a severe workplace injury
at Estes Express Lines, Inc., 64 Stefanak Drive, WEST MIDDLESEX, PENNSYLVANIA 16159
on — Electrical burns, unspecified, affecting the multiple body parts, n.e.c..
Final narrative
An employee was hooking up a trailer when they were struck by lightening. The employee sustained burns to the back and hands.
An employee was using a forklift to load material into a trailer when the trailer pulled away from the dock. The forklift and the employee dropped from the dock and the impact from the drop caused a vertebral fracture and lung bruising.
An employee was driving a forklift down a ramp after dropping off freight at a dock. The ramp was sweating, causing the employee to slide off the dock. The employee suffered a broken left hand.
An employee was completing a delivery when they slipped and fell on the snow and ice on a customer's steps, resulting in a right femur fracture and hospitalization.
An employee was operating and test-driving a forklift. The forklift struck a low metal post and overturned. The employee suffered a broken left leg, a dislocated left shoulder, a back hematoma, and a right foot laceration and was hospitalized.
An employee was installing a ground wire to a power transmission pole. The ground wire contacted an energized portion of a cut-out, causing an arc-flash. The employee was hospitalized with second degree burns to their chest and arms.
An employee was connecting a utility transformer for underground service to a home. The employee's impact drill went across two connection bars with 240 volts of potential, creating an arc flash. The employee sustained burns to the face and eyes due to the arc flash and molten aluminum.
On December 15, 2023, at 9:15 AM, an employee was changing 60-amp fuses in a 480-volt panel when an arc flash occurred. The employee was hospitalized with burns to both hands.
A truck driver was preparing a hose to load a chemical tanker trailer with sulfuric acid when sulfuric acid splashed the left side of their face and neck, causing skin burns.
An employee was disconnecting steam lines from a bulk liquid trailer. He disconnected a steam line located on a vapor recovery line when hot steam blew back onto him, resulting in burns to the left side of his abdomen, as well as his left arm and leg. The employee was hospitalized.
An employee was driving a truck when it lost power. He pulled over, opened the hood, checked the engine, and opened the radiator cap. Pressure in the radiator caused hot fluid to spew over the employee, who suffered second-degree burns to the left arm, hand, and leg.
An employee was walking into the motor control center (MCC) room when his right ring finger was caught in the hinge of a doorway. He sustained an open phalanx fracture, which resulted in a partial amputation above the first knuckle.
An employee was changing the spacing on a telehandler's forks. A fork slipped, and the employee's left index finger was caught between it and the mast. The fingertip was medically amputated at the first knuckle.
An employee was pulling down a broken skid with a forklift. When the employee backed up the forklift to get the forks out of the skid he pulled down, he contacted the forks of another parked forklift, fracturing both of his legs. He was hospitalized.
An employee was carrying cups back to the kitchen when her foot got caught on a cart and she fell face-first. During the fall, a piece of glass from a cup cut the inside of her mouth, severing an artery. She also sustained a laceration on her lower lip. The employee was hospitalized.