Federal Bureau of Prisons - FCI - Phoenix

An employee was troubleshooting the control setup for a variable air volume box above a ceiling. The employee's hand came into contact with an exposed, energized 277-volt wire that had loosened from its terminal on the box's assembly. He was shocked and fell off a ladder. His left hand passed across the ceiling grid and was lacerated. He also suffered an electrical burn to the right hand and was hospitalized.

An employee was working as a fire watch. The employee was exposed to anhydrous ammonia and was not able to see while climbing down a ladder due to eye irritation. The employee fell and was hospitalized for a broken ankle.

An employee was working from a ladder and adjusting a spreader guide roller with a T-handle Allen wrench. The employee came into contact with an electrical junction box/wires, was shocked, and fell off the ladder to the concrete floor. He suffered a broken right-side rib, a puncture in the right lung, and an electrical shock burn to the right palm.

An employee was on a 10-foot ladder, working to insulate 24-inch piping that was 12 feet above the ground. The pipe jack/steel tube used to raise the pipe slipped, causing the steel tube to strike the employee's face. The impact caused the employee to fall off the ladder and sustain fractures to their left tibia and fibula.

An employee was on a rooftop, supervising the lifting of a 30' x 30' structure manufactured from I-beams. The employee was knocked to the ground and the suspended load settled on them. The employee sustained a head injury, loss of an eye, and fractured ribs.

An employee was working in the food service warehouse when he experienced chest pain, difficulty breathing, and lost consciousness. The employee sustained carbon monoxide poisoning.

An employee was responding to a physical altercation between two inmates when they slipped and fell on the ground, landing on their left arm. The employee was hospitalized with a compound fracture to their left forearm.

An employee was working on an out-of-service forklift when his hand was caught in the door frame as the stuck cab door was being opened. The employee sustained a middle fingertip amputation.

An employee was closing a door while holding the door handle behind him. The door closed on his finger resulting in a fingertip amputation.

An employee placed his hand down and was shocked by electricity from a misting fan.

On September 25, 2025, an employee climbed an aluminum extension ladder and was on top of the roof of a building She was walking around on the roof, inspecting and evaluating it. She was descending the ladder when the ladder slid to the right and twisted around as she hung onto it. She then fell 10-12 feet to the paved parking lot and the ladder landed on top of her. She sustained a fractured left collarbone, multiple other fractures, and had bruising to the left side of her abdomen.

At about 5:55 p.m. on August 9, 2025, an employee lost his footing while climbing an access ladder to a 12-foot-high spotlight platform. He fell about 9 feet to the ground, breaking eight ribs on the right side.

On August 1, 2025, an employee was preparing to initiate canine training when they were bitten by a dog on the neck and face.

An employee was completing an annual work capacity test. Later that night, the employee experienced severe pain in their left leg and was hospitalized with rhabdomyolysis and compartment syndrome in the lower left leg.

An employee was setting chains to secure a concrete barrier to a front-end loader. The chain became twisted and lost slack. The concrete barricade fell on the employee's left foot, causing a partial amputation to a toe.