Contact with non-running objects or equipment unspecified · Amputations involving bone loss
At a glance
Federal OSHA recorded a severe workplace injury
at Rohr Inc., 1300 West Fern Ave, FOLEY, ALABAMA 36535
on — Amputations involving bone loss, affecting the Finger or thumb tip(s), nail(s).
Final narrative
An employee was un-pinning a part from a shipping crate that would be lifted out of the crate by an overhead crane. The pin consisted of both a pin and a sleeve. The pin was removed, however the sleeve remained in place. The employee then used her finger to help push out the pin sleeve. As the sleeve cleared the crate, the part abruptly moved upward due to the upward tension and caused a shearing impact to the employee's left ring finger. The employee sustained a fingertip amputation with an open fracture.
HospitalizedAmputation Finger or thumb tip(s), nail(s) Parts and materials unspecified
An employee was repairing the suspension of a semi-trailer. He was installing an air bag to the suspension when his left ring finger was crushed between the air bag and the suspension mounting beam. The employee was hospitalized.
An employee was dislodging a towbar and hitch between two golf carts. The upper part of the employee's left index finger was pinched in the towbar/hitch, causing an amputation at the last joint.
An employee was loading a motor onto a trailer when he struck his left elbow against the radiator. His elbow was lacerated and became infected, resulting in hospitalization.
An employee was helping a crew move a section of a grain conveyor that weighed 600-lbs into the proper configuration. The piece of equipment was sitting on a transport cart. While turning the cart to align it, the piece of equipment shifted and the employee's right middle finger was pinched in a small gap between the equipment and the cart. The employee pulled his gloved hand away and suffered a fingertip amputation.
On May 16, 2025, an employee was performing iron work. He was sliding a 3/4" x 2' x 4' bent plate across another plate to position it for installation. The bent plate crushed his left middle finger between the two steel plates. The distal bone was fractured and required a revision amputation.
More severe injuries in this industry (NAICS 336413)
An employee was walking from one building to another when he slipped on wet concrete and fell. The employee was hospitalized with a fracture and dislocation of the right patella.
An employee was working inside the access panel of a sliding door when the door began to shut. The employee's left middle finger was pulled into the chain and sprocket, resulting in amputation to the middle knuckle.
An employee was installing a rail on a machine. The roller pack was locked up, causing the chuck to not move. While manually removing the chuck, the rails were damaged. As a result, both the roller pack and the rail needed to be replaced. A fixed magnet from above the rail pulled the rail up and rolled it, pinching the employee's thumb between the rail and the magnet when he tried to install the new rail back to the position. The right thumb tip was amputated.
An employee was traveling down the maintenance aisle of a warehouse on a single-pallet front rider jack. The jack malfunctioned, causing the brakes to apply; the employee fell forward onto the concrete warehouse floor. The employee suffered an injury to the left leg and was hospitalized, requiring surgery.
An employee was operating a metal roller machine to roll a small piece of metal. The employee's right index finger became caught between the metal and the machine, and the fingertip was amputated.
An employee was directing a truck driver to a dump site when the truck's peanut trailer slipped off the kingpin. As the trailer fell, a ladder attached to it lacerated the employee's ear. The employee was hospitalized.
An employee was unloading a forklift from a trailer to the ground. The employee was climbing down the ladder of the trailer when their foot slipped through one of the rungs, causing them to fall backward onto the forklift forks. The employee was hospitalized for fractured ribs.