Federal OSHA recorded a severe workplace injury
at General Mills, 3007 Stephens Blvd, JOPLIN, MISSOURI 64804
on — Fractures , affecting the Thigh(s).
Final narrative
An employee was troubleshooting a palletizer that wasn't working. While walking on the conveyor, the employee jumped to reach a photo eye and fell on his leg, resulting in a fractured femur.
An employee was changing the belt of a sorting machine. He was on his knees, changing the drive belt under the machine, when lost his balance and hit his head on the framework. He suffered an injury that caused numbness in both arms and hands and was hospitalized.
An employee went to grab his lunch box from a table in the breakroom. He rotated, took a few steps, and then fell to the floor. The employee sustained right femur fracture and was hospitalized.
An employee was operating a forklift and picking a pallet when the vehicle contacted a nearby parked forklift that had the forks raised. The employee sustained a left foot fracture and laceration.
An employee was dumping frozen meat into a tote dumpster when a chunk of frozen meat came out and hit the rake. The rake fell and crushed her right little finger against the edge of the tote dumpster, resulting in an open fracture.
An employee was moving a 3-ton condensing unit, strapped down on a dolly, out of a garage. The strap broke, causing the employee to fall backward onto the brick pavered driveway. The employee suffered injury to a spinal ligament in the neck.
An employee was talking to a child on the playground, when the child grabbed her hand to lead her away. The employee stepped, lost her balance, and fell over. The employee was hospitalized with a fracture of her lower left leg and required surgery.
An employee was lowering a safe stack beam inside a trailer. The beam released, causing the employee to fall back and strike his head on the trailer floor. He was hospitalized with a brain bleed and a concussion.
An employee was on the ground working to close a trailer door. The door was caught by the wind and blew the employee backward. He landed on his back and sustained four fractured ribs, requiring hospitalization.
An employee was performing maintenance under a kettle. When he removed a tri-clamp on a transfer line, the hot fat and broth material in the kettle poured out onto his arm. The employee was hospitalized with burns.
An employee was walking on top of boiler to close a valve. The employee fell off the boiler and landed on the floor, sustaining fractured ribs. The employee was hospitalized.
An employee was inspecting a pipe in the rice cooking area near an oven. While checking for a clog, the fingers of their right hand were caught in an airlock at the base of the pipe. All the fingers were amputated except the thumb. The employee was hospitalized.
An employee was readjusting a safety hook to remove hardware from gang forms when his feet slipped. He fell to the ground, resulting in a broken left arm and wrist.
An employee was on a step ladder in a store aisle, making room on shelving for merchandise. She fell from the step ladder to the floor, suffering two fractures in her left leg. She was hospitalized, requiring surgery.
An employee was closing the side cargo door to a company van. The tip of his finger got caught between the door and the door jamb, resulting in a partial amputation.
An employee lost his footing while climbing an inclined ladder. He stumbled down one step and was able to stabilize himself by holding the railing and twisting his body, but he suffered an internal abdominal injury and was hospitalized.