Federal OSHA recorded a severe workplace injury
at Primoris T&D Services LLC, 2002 Moore St, SHERMAN, TEXAS 75090
on — Amputations, avulsions, enucleations unspecified, affecting the Finger or thumb tip(s), nail(s).
Final narrative
An employee was loading a large jackhammer when his hands were pinched between the loader mast and the rigging chain. The employee sustained a fingertip amputation.
Amputation Finger or thumb tip(s), nail(s) Bucket, front-end, and pay loaders
An employee was in a bucket truck installing a ground bus within a transformer cabinet when a high-voltage arc flash occurred. The employee suffered first-, second-, and third-degree burns to the left arm and left side of the torso.
A three-person crew was inter-setting a new utility pole. An employee was working to cut the conductor when a 14.4-kV arc flash occurred. The employee sustained burns to the upper-right torso. The employee was wearing personal protective equipment (PPE), including flame-resistant clothing, rubber gloves, and sleeves.
An employee was unhooking a trailer from a vehicle when the trailer rolled backward over their left leg. They sustained a laceration to the inner thigh and an ankle fracture, resulting in hospitalization.
An employee was climbing a pole to pick up a powerline that was downed due to a storm when their hand contacted a 7,200-volt distribution line, resulting in an electrical shock.
A crew was installing drilled micropiles alongside an outdoor covered deck foundation. The injured employee was working the front of the drill when a loose section of casing dropped onto the tip of a rig wrench and pulled the wrench down to an embedded casing. The employee's left little finger was caught between the rig wrench and the embedded casing and was amputated above the top knuckle.
An employee was checking a pole-type transformer tank for leaks. A hydraulic clamping device was lowered onto his right thumb and crushed it against the sharp edge of the bottom of the tank. He suffered a partial transphalangeal amputation to the thumb.
An employee had been cleaning the work area. While lifting a saw, the employee's index finger was lacerated by the saw blade. A tendon was cut and required surgery.
An employee was installing a hydraulic extension cylinder in a tow truck when their leg was caught between the cylinder and the truck frame. The employee was hospitalized with a broken tibia, which required surgery.
An employee was sorting sucker rods. His right hand was caught in the area where the rod hits up against the frame and his index fingertip was amputated just below the nail.
More severe injuries in this industry (NAICS 237130)
An employee was terminating cables in a junction box. A loose ground wire came into contact with the bushing, causing a flash that burned the right side of the employee's face and his right hand.
An employee was using a bucket truck hoist to raise secondary aerial wiring. The wire made contact with the primary wire, causing an arc flash. The employee suffered burns to both hands and was hospitalized.
An employee was terminating conductors to buss bars inside the secondary compartment of a single-phase transformer. An arc flash occurred, causing burns to the soft tissue of the employee's face.
An employee was securing the claw of a grapple truck to the truck bed. His left little finger was caught between the tie down strap and the rub rail of the truck, resulting in partial amputation of the finger.
After cutting a slab of beef short ribs, an employee turned to grab the pieces he had cut and his right hand contacted the saw blade. The employee sustained an amputation to his right index finger.
An employee was unloading a carpet pad from a truck when they fell from the truck dock to the concrete below, resulting in five fractured ribs and an injury to their left lung.
An employee was walking up a walkway to enter a building through the back entrance when she tripped over the lip of the cement ramp. The employee fell and sustained a fractured right hip.