Struck by suspended or swinging objects n.e.c. · Multiple severe wounds and internal injuries
At a glance
Federal OSHA recorded a severe workplace injury
at Bechtel Energy Construction Services Inc., Port Arthur LNG, PORT ARTHUR, TEXAS 77640
on — Multiple severe wounds and internal injuries, affecting the Multiple trunk locations.
Final narrative
At 9:44 p.m. on October 9, 2024, an employee was helping rig and move a bundle containing about 30 pieces of 48-foot, 6-inch rebar. The employee was caught between the moving rebar bundle and a landed stationary rebar bundle, suffering a liver laceration and a non-displaced fracture of the tenth rib.
An employee was standing on a sheet of -inch by 4-foot by 8-foot plywood on top of a rebar mat, supervising his crew. As he was moving to alert the crew to an incoming overhead load, he stepped off the plywood and his left foot slipped through the rebar mat and landed on the rebar mat below. His left ankle was broken and dislocated.
An employee was assisting three coworkers with loading a fall protection metal storage cage onto a wooden pallet. Their right index finger was pinched between the pallet and the bottom of the cage, resulting in a fingertip amputation.
On July 3, 2025, at approximately 9:45 PM, an employee was operating a utility task vehicle (UTV) on a project road when the UTV struck the rear of a reversing bulldozer. The employee struck their head and face on the UTV dashboard and collapsed onto a UTV passenger. The employee was hospitalized with a forehead laceration, a nasal fracture, and central cord syndrome. The other employee on the UTV sustained a bruised left forearm and was not hospitalized.
An employee was cutting a synthetic securing strap from a bundle of I-beams. One end of an I-beam rolled off the skid and struck the employee's legs, fracturing both fibulas.
An employee was walking into the motor control center (MCC) room when his right ring finger was caught in the hinge of a doorway. He sustained an open phalanx fracture, which resulted in a partial amputation above the first knuckle.
An employee was stacking concrete blocks for a concrete bunker. As a block was swinging into place, the employee's left leg was pinched between two blocks, resulting in injuries to his left heel and lower leg.
An employee was using a crane to move a 44-foot, 3,343-pound I-beam. As the beam was moving west, it straightened out (north to south), beginning to swing south toward the northwest corner of a building. The crane then sent the beam southward, directly toward the corner of the building. The beam caught the tips of the employee's left index, middle, and ring fingers against the building. The last joints of the middle and ring fingers were amputated, and the last joint of the index finger was partially crushed.
An employee was placing a board on top of a bundle of steel tubing. A crane was moving a bundle of steel that struck the employee and caught them against another bundle of steel tubing. The employee sustained a crushing injury and hematoma to the right upper leg.
Employees were using a crane to lower large tree stems and branches while removing limbs and branches from the load. This caused the load to shift and strike an employee in the back, resulting in a hematoma on the lower left part of their back and a fractured ankle.
More severe injuries in this industry (NAICS 236220)
The injured employee was standing behind a table. She jumped out to scare another employee, but tripped and fell on the tile floor, injuring her right ankle/foot. She was hospitalized with a dislocated ankle that required surgery.
An employee was installing insulation in a wall when she tripped on a hole (12" deep) and fell, hitting her head on the concrete floor. The employee sustained fractures to her leg and wrist, and lacerations to her head. The employee was hospitalized.
An employee was loading a 4-inch wooden door into a pickup truck when he felt a pop in his right side behind his shoulder blade. He was hospitalized later that day and underwent surgery, having suffered a collapsed right lung.
After cutting a slab of beef short ribs, an employee turned to grab the pieces he had cut and his right hand contacted the saw blade. The employee sustained an amputation to his right index finger.
An employee was unloading a carpet pad from a truck when they fell from the truck dock to the concrete below, resulting in five fractured ribs and an injury to their left lung.
An employee was walking up a walkway to enter a building through the back entrance when she tripped over the lip of the cement ramp. The employee fell and sustained a fractured right hip.