ELGIN, ILLINOIS—
John Burns Construction Company
Direct exposure to electricity greater than 220 volts · Thermal burns degree unspecified
At a glance
Federal OSHA recorded a severe workplace injury at John Burns Construction Company, 375 W River Rd, ELGIN, ILLINOIS 60123 on — Thermal burns degree unspecified, affecting the Upper and lower extremities n.e.c..
Final narrative
An employee was working on switchgear equipment and contacted a cubicle. The employee sustained an electrical shock (12.5 kV) and burns to the left hand and right ankle.
Similar incidents · Same event type
ASSUMPTION, ILLINOIS—
J F Electric, Inc.
A crew was changing out a single-phase pole. The injured employee was framing the pole approximately 30 feet from the base. As they were loosening the armor rod clamp, the conductor broke and the wire fell to the ground, landing on the employee's right hand. The employee suffered electrical burns to their right hand and both knees.
COLLINSVILLE, ALABAMA—
Cherokee Electric Cooperative
An employee (a lineman) was working to restore power by installing a hand line when he contacted a high-voltage device (7,200 volts), resulting in electrical burns to his upper body and hands.
STEPHENVILLE, TEXAS—
Scott Pole Line, LLC
An employee was working from a bucket truck to remove a bolt from an attachment on an energized power line pole. The employee came into contact with the energized phase, resulting in an electrical shock of 7,200 volts. The employee was hospitalized. Protective gloves were not worn at the time of the incident.
WASHINGTON COURT HOUSE, OHIO—
Mega Communications
On September 29, 2025, an employee was installing a fiber optic line at a residential site. His shoulder contacted the 7,600-kilowatt power line, resulting in an electrical shock. The employee was hospitalized.
BENNINGTON, OKLAHOMA—
Metts Powerline Construction, Inc.
Two employees exited their vehicle to assess a fully-downed power pole. The injured employee approached the downed pole to examine it more closely when their feet got caught underneath the energized phase and the ground of the pole, resulting in electrical burns to both feet.
More severe injuries in this industry (NAICS 237310)
SYRACUSE, NEW YORK—
Cashless Tolling Constructors
An employee was operating a battery-powered broom to clean demolition debris off the top of the outermost bridge girder. The girder was approximately 11 feet above the demolition scaffold below. The employee fell approximately 8 feet to wind bracing below. The employee was hospitalized with a pelvis/tailbone fracture. Fall protection was in place at the time.
CRESTVIEW, FLORIDA—
Anderson Columbia Co., Inc.
An employee was cleaning out an inlet pipe in a stormwater structure. The employee stepped back, fell into the pipe, and landed on concrete 13 feet below, at the bottom of the structure. He suffered a broken back.
DENVER, COLORADO—
FLATIRON CONSTRUCTION CORP.
A concrete batch plant operator was assisting with clearing spoil piles using a skid steer. The skid steer backed into a stationary screen plant. The employee's left little finger was crushed between the controls of the skid steer and the screen plant, resulting in a fracture and laceration. The employee's finger was surgically amputated.
NORTHAMPTON, MASSACHUSETTS—
Warner Brothers, LLC
An employee was operating a roller and paving a small pathway next to a pavilion. The ground was on a slight pitch, causing him to reach up toward the roll cage to stabilize himself. His right fifth finger was pinched between the roll cage and the rafter of the pavilion. The employee sustained a partial degloving injury with partial traumatic amputation.
NORWOOD, MASSACHUSETTS—
Don Martin Corporation
An employee was working with paving equipment and heard a noise on the opposite side of the machine he was working on. When the machine stopped, the employee went to the opposite side and crouched down to investigate the noise. A mini track loader backed up and drove over the employee's leg. The employee sustained fractures to their lower leg, ankle, and foot.
More severe injuries in ILLINOIS
ROUND LAKE, ILLINOIS—
Takeda Pharmaceuticals U.S.A., Inc.
An employee fell while moving a water canister, resulting in fractures to four fingers on her right hand.
KEWANEE, ILLINOIS—
Great Dane Ltd. Partnership
An employee was changing a die in a press when the die slipped and crushed the employee's left index finger. The employee sustained an open facture of the tuft of the left distal phalanx and a partial amputation.
FRANKLIN PARK, ILLINOIS—
Olympia Food Industries Inc.
An employee was mixing sauce using a sauce barrel mixer when his left little finger was amputated.
NORTH CHICAGO, ILLINOIS—
AbbVie Inc.
An employee was driving a boom lift (in the lowered position) in an exterior dock area. The lift s left wheels rolled onto base plates that covered a 3-foot-deep sump pit. The base plates failed, and one side of the lift dropped. The employee's left leg was caught under the lift basket, and he suffered a fracture to the lower leg including the ankle.
MONTGOMERY, ILLINOIS—
TSA Processing - Montgomery
A temporary employee was carrying a nail gun through the warehouse when it hit his leg, activated, and fired a nail into the leg.