Exposure to harmful substance multiple routes of exposure · Effects of poison, toxic, or allergenic exposure unspecified
At a glance
Federal OSHA recorded a severe workplace injury
at Pemco World Air Services, Inc, 4420 N West Shore Blvd, TAMPA, FLORIDA 33614
on — Effects of poison, toxic, or allergenic exposure unspecified, affecting the BODY SYSTEMS .
Final narrative
An employee was performing a maintenance test of a hydraulic component (case drain overheat switch) that involved disconnecting the hose/switch. Hydraulic fluid began leaking and the employee went to reconnect the hose/switch but fire-resistant hydraulic fluid sprayed the employee's face, eyes, and mouth. The employee ingested some of the hydraulic fluid.
Hospitalized BODY SYSTEMS Lubricating fluids
More severe injuries at Pemco World Air Services, Inc
An employee was preparing the aft cargo door of an aircraft for painting, while standing on a ladder. The employee was using a grinder and wearing a half-mask respirator when he fell to the hangar floor. The employee sustained a dislocated elbow requiring surgery.
An employee was removing contaminants from a low point drain on an ammonia line through a hose and into a container of water. A release of pressure from the end of the hose exposed the employee to anhydrous ammonia, resulting in chemical burns to his face, arm, and chest as well as ammonia inhalation. He was hospitalized.
An employee was performing preventative maintenance on a tanker trailer. He moved a hose for an inspection date and residual liquid toluene diisocyanate (TDI) came out of the hose and onto the employee's face, eyes, and hands. He was hospitalized with breathing issues.
An employee was changing out a hose on a chemical tote. The fitting for the tote disengaged and the employee was exposed to peracetic acid that caused chemical burns and respiratory distress.
An employee was working to unplug a 1.5-inch hydrated lime injection nozzle and disconnected a flexible hose at a camlock fitting to access the nozzle. When the line cleared, the hydrated lime released the blockage and blew into the employee's face. The employee ingested and inhaled hydrated lime (a respiratory irritant) and was hospitalized.
An employee was operating a press. A billet was uneven as it entered the loader; it hit the ram and then sheared off a hydraulic line, which sprayed hydraulic fluid into the employee's mouth and was ingested. The fluid was ignited, and the fireball caught the employee's hair on fire and he sustained first-degree burns to his forehead and hand. Ingestion of the fluid and inhalation of the fumes affected the employee's airway. He was hospitalized.
More severe injuries in this industry (NAICS 488190)
Two employees fell from an access bridge while entering an aircraft to perform maintenance. They landed on the ground about 20 feet below, where one of them lost consciousness. One employee sustained a fractured knee and another employee sustained a back strain/sprain. Both employees were hospitalized.
An employee experienced sharp pain in his lower torso area while loading baggage into the front cargo pit of an aircraft. The employee sustained a hernia.
The injured employee was assisting in the disassembly phase after a radar array had been lowered and secured. The crew began removing load bearing pins from an overhead crane to free the radome. A load bearing pin was stuck. The injured employee went to remove the pin manually as a second team member applied pressure from the opposite side. The pin unexpectedly released and struck the injured employee s right thumb, resulting in partial amputation of the distal phalanx including an open distal phalanx fracture and nail bed laceration.
On September 11, 2025, an employee was lowering a railing system on an aircraft fueling cart when his gloved right ring finger was caught in the folding railing system, resulting in a fingertip amputation that required hospitalization and surgical reattachment.
An employee was working at ground level when an aviation engine cylinder weighing 30 pounds fell from a seven-foot high shelf and struck the employee on the head. The employee suffered a fractured skull and was hospitalized.
An employee was helping a coworker transport a tall palm tree with a mini skid steer. The employee was severely shocked by a high-voltage electrical wire above the ground.
An employee was retrieving a Christmas tree from a shelf using a ladder. He missed a step and fell to the concrete floor. He sustained injury to his head and wrist.
An employee was operating an agricultural tractor during sugarcane harvesting. The employee sustained a lumbar sprain due to vibration or motion from the tractor.
An employee was moving a 3-ton condensing unit, strapped down on a dolly, out of a garage. The strap broke, causing the employee to fall backward onto the brick pavered driveway. The employee suffered injury to a spinal ligament in the neck.