Stepped on object · Heat (thermal) burns, unspecified
At a glance
Federal OSHA recorded a severe workplace injury
at GOTTLIEB INCORPORATED, 5603 GRAND AVENUE, NEVILLE ISLAND, PENNSYLVANIA 15225
on — Heat (thermal) burns, unspecified, affecting the lower extremities, unspecified.
Watch Gottlieb Incorporated — freeGet an email when a new federal OSHA severe-injury report for Gottlieb Incorporated is published. One employer, no account, unsubscribe in one click.
Final narrative
An employee was hospitalized after stepping into molten aluminum. Employee was burned several inches up his boot by the molten aluminum.
HospitalizedLower extremities, unspecifiedMolten or hot metals, slag
An employee was attempting to remove aluminum product that had jammed a conveyor when the conveyor activated, catching his thumb in the chain that makes it move. He was hospitalized with a broken right arm, wrist, and middle finger, and his right thumb was partially amputated.
On May 22, 2023, an employee was working as a framer and knelt on a nail that was on the ground. The nail penetrated his knee and entered the bone. He was hospitalized.
An employee was stepping down from one level to another, about 10 inches below, when he lost his balance and stepped on a protruding 3/8-inch rod. The rod punctured the sole of his right foot.
An employee was carrying a box of screws. The box flipped over and screws fell to the floor. One of them punctured his bootheel and the bottom of his right foot.
An employee was walking on the loading dock when a nail entered the sole of his shoe and punctured his foot. The employee sustained an infection and was hospitalized.
More severe injuries in this industry (NAICS 423510)
A load of steel angles was being lowered when the lifting chain hit the load, causing it to slide toward an employee. An angle slid and pinched the employee, catching both of their legs between the beams and an angle. The employee suffered two fractured legs.
An employee was on the deck of a trailer helping a customer unload tubes. The employee was working to place a cargo strap on the remaining tubes using a winch bar when it slipped off the tubing, causing him to lose his balance and fall headfirst onto the asphalt lot below. The employee suffered a contusion on his forehead, resulting in hospitalization.
An employee and a customer were unloading two rectangular tubes. The tubes were wrapped together. The plastic wrap was cut so that one tube could be picked up. As the employee was lifting the top tube, the other tube (still connected to the top tube) came down onto his hand and broke two of his fingers. He was hospitalized.
An employee was assisting as a forklift got pipe from a pipe rack. The employee was on one of the forklift's forks as it was raised to the top of the rack, a height of about 15 feet. He fell to the ground and suffered a dislocated and fractured right elbow.
On September 23, 2025, at approximately 7:43 p.m., an employee was using a knife to cut poly banding from a metal coil. The knife slipped, causing a laceration to the inside of their left arm at the elbow joint. The employee was hospitalized and required surgery to repair a damaged vein.
An employee was walking into the motor control center (MCC) room when his right ring finger was caught in the hinge of a doorway. He sustained an open phalanx fracture, which resulted in a partial amputation above the first knuckle.
An employee was changing the spacing on a telehandler's forks. A fork slipped, and the employee's left index finger was caught between it and the mast. The fingertip was medically amputated at the first knuckle.
An employee was pulling down a broken skid with a forklift. When the employee backed up the forklift to get the forks out of the skid he pulled down, he contacted the forks of another parked forklift, fracturing both of his legs. He was hospitalized.
An employee was carrying cups back to the kitchen when her foot got caught on a cart and she fell face-first. During the fall, a piece of glass from a cup cut the inside of her mouth, severing an artery. She also sustained a laceration on her lower lip. The employee was hospitalized.