SHIPPENSBURG, PENNSYLVANIA—
JLG Industries, Inc.
Pedestrian struck by vehicle backing up in nonroadway area · Fractures
At a glance
Federal OSHA recorded a severe workplace injury at JLG Industries, Inc., 560 Walnut Bottom Road, SHIPPENSBURG, PENNSYLVANIA 17257 on — Fractures, affecting the multiple body parts, n.e.c..
Final narrative
An employee was checking the back of a tractor-trailer for obstructions. The tractor-trailer driver lost sight of the employee while backing up and struck him. He suffered a broken leg, two broken ribs, and a road rash injury to the scalp.
More severe injuries at JLG Industries, Inc.
SHIPPENSBURG, PENNSYLVANIA—
JLG Industries, Inc.
An employee was winching in the mid-section of a boom on an aerial lift into the base section when their left middle and ring fingers were pinched between the two sections of the boom subassembly. The employee sustained a displaced fracture of the middle phalanx of their left middle finger and the amputation of their left ring fingertip.
GREENCASTLE, PENNSYLVANIA—
JLG Industries, Inc
An employee was preparing to use a programmable automated vertical band saw. The employee was clamping a piece of angle iron in place on the machine when the clamp caught the employee's left index fingertip. The employee suffered an amputation to the fingertip, up to the edge of the nail.
BEDFORD, PENNSYLVANIA—
JLG Industries, Inc
An employee was preparing a new lift to receive an engine. His right pinky finger was pinched and he sustained a loss of soft tissue.
MC CONNELLSBURG, PENNSYLVANIA—
JLG Industries Inc.
An employee was standing on the floor inspecting parts for paint quality. When he was finished looking at a part, he starting walking backwards and tripped on a wooden pallet that was laying on the floor behind him. He fell to the concrete floor and fractured a hip.
GREENCASTLE, PENNSYLVANIA—
JLG Industries, Inc.
A welder was removing a steel production part from a welding fixture using an overhead crane. He connected the lifting hook to the steel part's center post, then applied tension to the overhead crane. His little finger was pinched between the lifting hook and the steel part, causing the amputation of the tip.
View JLG Industries, Inc.'s full OSHA safety record →
Similar incidents · Same event type
MIAMI, FLORIDA—
Bauducco Foods, Inc.
An employee was walking in an aisle when a forklift backed up over her foot, resulting in a skin injury that required surgery to repair.
EAST LIVERPOOL, OHIO—
S. H. Bell Company
An employee was looking into the bucket of a front-end loader to see how much material was in it. A skid steer backed into the employee, who then fell into the edge of the front loader's bucket and suffered internal bleeding in the abdominal area.
NEWPORT, RHODE ISLAND—
SHM Newport Shipyard, LLC
An employee was spotting for a forklift operation. The forklift backed over the employee, who suffered a complete amputation to one lower leg and a partial amputation to the other leg. The employee was hospitalized.
CORSICANA, TEXAS—
Oil City Iron Works, Inc.
An employee was cleaning his work area and preparing it to begin making air-set molds
when a nearby forklift that was backing out from a load swung around and struck the employee. They sustained a lower left leg fracture.
AMERICAN FALLS, IDAHO—
Canyon Falls Farms
An employee was walking around a work area when he was struck by a forklift that was backing up, resulting in several broken bones in his foot.
More severe injuries in this industry (NAICS 333120)
HURON, SOUTH DAKOTA—
Riverside Industries LLC
An employee was working behind a stack of steel I-beams (stacked 2 columns deep and 4 levels high on the floor) while a forklift was pushing the stack. When the forklift took off the second-to-last beam, the last one was pushed over, causing it to fall to the ground and strike the employee. The employee sustained a fracture to the right leg.
BISMARCK, NORTH DAKOTA—
Bobcat Company
An employee was lifting a flat sub (sheet steel) in the flats robot cell (weld area). He was operating a hoist when his left little fingertip got caught between the lifting device hook and the flat sub. The employee sustained a partial transphalangeal amputation.
BALCH SPRINGS, TEXAS—
Altec Service Center
An employee was underneath a 35-foot boom truck and adjusting the transmission linkage when the truck jumped over the wheel chocks and rolled over the employee's right leg, resulting in a fracture.
NEW PHILADELPHIA, OHIO—
GRADALL INDUSTRIES, INC.
A crane was being used to lift a debris tank from a rack. The tank crushed the employee's right hand, causing amputations to the employee's right ring finger and little fingertip.
MADISON, SOUTH DAKOTA—
Manitou Equipment America, LLC
An employee was removing a small sheet metal part out of the die of the brake press. The foot pedal was pressed, causing the part to lift and crush their left thumb against the die. The employee suffered an amputation to the thumb tip including the loss of flesh and the fingernail.
More severe injuries in PENNSYLVANIA
WYNNEWOOD, PENNSYLVANIA—
Main Line Clinical Labs
An employee was closing a door when the door closed on their right index finger, resulting in a fingertip amputation.
POCONO SUMMIT, PENNSYLVANIA—
Ardent Mills
An employee was walking into the motor control center (MCC) room when his right ring finger was caught in the hinge of a doorway. He sustained an open phalanx fracture, which resulted in a partial amputation above the first knuckle.
LANCASTER, PENNSYLVANIA—
Zimmerman & Herr
An employee was changing the spacing on a telehandler's forks. A fork slipped, and the employee's left index finger was caught between it and the mast. The fingertip was medically amputated at the first knuckle.
EBENSBURG, PENNSYLVANIA—
McAneny Brothers, Inc.
An employee was pulling down a broken skid with a forklift. When the employee backed up the forklift to get the forks out of the skid he pulled down, he contacted the forks of another parked forklift, fracturing both of his legs. He was hospitalized.
PITTSBURGH, PENNSYLVANIA—
Metz Culinary Management LLC
An employee was carrying cups back to the kitchen when her foot got caught on a cart and she fell face-first. During the fall, a piece of glass from a cup cut the inside of her mouth, severing an artery. She also sustained a laceration on her lower lip. The employee was hospitalized.