KATY, TEXAS—
Tesla, Inc
Other fall to lower level 11 to 15 feet · Fractures
At a glance
Federal OSHA recorded a severe workplace injury at Tesla, Inc, 3822 Emery highs lane, KATY, TEXAS 77494 on — Fractures, affecting the ankle(s).
Final narrative
An employee was transitioning from one rope to another rope on a rooftop when he slipped and fell approximately 12 feet 8 inches to the ground. The employee sustained a displaced, closed fracture to the right ankle.
More severe injuries at Tesla, Inc
AUSTIN, TEXAS—
Tesla, Inc.
An employee was inspecting a casted part that weighed 330 pounds. The part fell from a lift assist onto the employee, striking his upper right arm and head. He suffered burns to the upper right arm and was hospitalized.
AUSTIN, TEXAS—
Tesla, Inc.
On June 4, 2025, an employee was skimming molten aluminum when it dripped down from the skimming spoon onto the employee's left pant leg, burning the top of their left foot. The employee was hospitalized and required surgery.
AUSTIN, TEXAS—
Tesla, Inc.
An employee was loosening the legs of a metal desk on the production floor to adjust the height when the desk collapsed onto the employee's right hand, resulting in amputation of the thumb tip.
AUSTIN, TEXAS—
Tesla, Inc.
An employee was transferring molten aluminum into a sow (mold). Condensation dripped from a pipe located above the area into the sow as it was staged to fill. When the molten aluminum came into contact with the water, the molten aluminum reacted and was released into the air, contacting the employee. They sustained burns to their chest, neck, and bilateral upper extremities.
AUSTIN, TEXAS—
Tesla, Inc.
An employee was using a ladder to access a roof to install conduit pipes when the ladder slipped on patio tile and came out from under him, causing him to fall approximately 8 feet to the ground. The employee suffered a spinal fracture and brain bruising.
View Tesla, Inc's full OSHA safety record →
Similar incidents · Same event type
DEERFIELD, MISSOURI—
ADM
The employee was on top of a rail car to level the grain that was deposited into the car when they fell 13-15 feet to the ground. The employee sustained a right leg fracture.
MENTONE, TEXAS—
International Game Technology
An employee was on an extension ladder installing a satellite dish on a roof when they fell approximately 12-15 feet to the ground. The employee sustained fractures.
JACKSONVILLE, FLORIDA—
WW Gay Mechanical Contractor, Inc.
An employee was setting a 5-foot pry bar into a precast concrete slab and stood on the end of the pry bar to move the slab into place. The pry bar slipped out causing the employee to fall backward 15.5 feet to the dirt ground. The employee was hospitalized with a broken leg.
CANAAN, CONNECTICUT—
Konecranes, Inc.
An employee was on a step ladder to measure and mark a crane rail for modification. The employee fell approximately 12 to 15 feet to the ground, resulting in a fractured right hip.
BROOKVILLE, PENNSYLVANIA—
Maximus Group
An employee was on a trailer securing a load of logs when they fell approximately 9-12 feet to the ground. The employee sustained brain hemorrhaging and lacerations to the thigh and above the eye. The employee was hospitalized.
More severe injuries in this industry (NAICS 221114)
BENTON, MAINE—
Longroad Energy
An employee was standing on a step stool, removing the nuts and bolts from the frame of a solar panel that was being replaced. The employee's cheek made contact with a connector with damaged insulation. The employee was shocked, briefly lost consciousness, and fell to the ground, suffering an injury to the left shoulder.
APOLLO BEACH, FLORIDA—
Tampa Electric Company
An employee was changing fuel filters on a front-end loader. When he descended the access steps of the engine bay, he misstepped and fell approximately 3 feet to the concrete surface below. The employee sustained a fractured left hip.
PATASKALA, OHIO—
Illuminate USA
An employee was walking in the warehouse when their foot was struck by the forks of an unloaded forklift that was passing by. The employee's foot was fractured.
ALLENTOWN, PENNSYLVANIA—
Big Wave Roofing and Solar
An employee was climbing down an extension ladder from a residential roof. The ladder collapsed under his foot, and he fell backward onto the grass. He suffered a sprained neck, a fractured scapula, and fractures to his T7 and T12 vertebrae.
PATASKALA, OHIO—
Illuminate USA
An employee was working to straighten a solar panel by reaching into the unguarded rotating section of the conveyor when their right thumb got caught in the conveyor, resulting in amputation of their right thumb.
More severe injuries in TEXAS
EAST BERNARD, TEXAS—
T G Meat Center LLC
After cutting a slab of beef short ribs, an employee turned to grab the pieces he had cut and his right hand contacted the saw blade. The employee sustained an amputation to his right index finger.
LUBBOCK, TEXAS—
Professional Flooring Supply
An employee was unloading a carpet pad from a truck when they fell from the truck dock to the concrete below, resulting in five fractured ribs and an injury to their left lung.
HOOKS, TEXAS—
EnviroSafe Demil LLC
An employee was inspecting flares processes. The employee received burns to the front side of the body, face and arm from the flares.
LOLITA, TEXAS—
Inteplast Group
An employee was removing plastic material from a production line when the machine cycled and amputated his left index, ring, and little fingers.
HALLETTSVILLE, TEXAS—
Regency IHS of Fairwinds Halletsville, LLC
An employee was walking up a walkway to enter a building through the back entrance when she tripped over the lip of the cement ramp. The employee fell and sustained a fractured right hip.