GOOSE CREEK, SOUTH CAROLINA—
BAE Systems
Contact with objects and equipment, n.e.c. · Amputations
At a glance
Federal OSHA recorded a severe workplace injury at BAE Systems, Charleston Army Strategic Logistic Activity Center, GOOSE CREEK, SOUTH CAROLINA 29445 on — Amputations, affecting the finger(s), fingernail(s), n.e.c..
Final narrative
While climbing down a military vehicle (MMPV) access ladder, the employee's wedding ring on his left hand got caught on one of the anti-slip barbs on the step. When he dismounted the last step, the flesh was pulled from his ring finger, resulting in its ultimate amputation.
More severe injuries at BAE Systems
YORK, PENNSYLVANIA—
BAE Systems
An employee was walking when his foot caught residual adhesive from floor tape and he tripped and fell to the concrete floor, resulting in a fractured right hip.
YORK, PENNSYLVANIA—
BAE Systems
An employee was using a powered pallet jack to move a fixture. His leg became caught between the pallet jack and the fixture and he fell on the same level, resulting in a fractured left fibula.
ANNISTON, ALABAMA—
BAE SYSTEMS
The injured employee was trying to hold a door open for another employee when the automatic door closed on the injured employee's left ring finger. The employee's fingertip was amputated halfway down the fingernail.
SAN DIEGO, CALIFORNIA—
BAE Systems
An employee was inside a mid-level ballast tank onboard an amphibious transport dock (naval vessel). He was walking across the deck and stepped onto a board that was covering an open hole. The board split and the employee fell about 15 feet to the bottom of the tank. He sustained internal bleeding, a brain hematoma, and fractured the C6 and L1 vertebrae.
ANNISTON, ALABAMA—
BAE SYSTEMS
While adjusting the rigging for the bull gear installation, the bull gear became unstable and shifted. The shifting gear contacted the mobile platform on which the employee was standing knocking the platform over and causing the employee to fall to the ground. When the gear shifted, the employee's right index finger was caught between the rigging and the wood block resulting in amputation of the finger.
View BAE Systems's full OSHA safety record →
Similar incidents · Same event type
LOMPOC, CALIFORNIA—
Federal Bureau of Prisons
An employee was preparing the serving line area for the evening meal. He was cleaning a stainless steel table when his left middle finger got stuck in a gap where a raised ledge is affixed to the table. As he pulled his finger from the space, his fingertip was amputated.
CLINTON, MASSACHUSETTS—
Shaw's Supermarket
An employee was unloading goods from a pallet and putting them onto metal shelves when their wedding ring got caught on a shelf and their finger was amputated.
FARMINGTON, CONNECTICUT—
Beebe Landscape Services, Inc.
An employee was in the back of a dump truck emptying a bag from a mower. When he placed his hand on the side of the truck and as he came down from the truck, his ring became caught. The employee sustained an amputation to his ring finger.
GREEN BAY, WISCONSIN—
American Foods Groups LLC
On May 18, 2023, a maintenance employee was descending a fixed ladder when his ring was caught on a ladder rung. The employee sustained a fracture to the left ring finger that required surgery.
BOISE, IDAHO—
Ferguson Waterworks
An employee was unloading a pipe from a fitted rack on his truck. As the employee grabbed a pipe strap, his glove became caught. The employee then went to step off the back of the truck and the top inch of his left hand ring finger was partially amputated.
More severe injuries in this industry (NAICS 811111)
SAN ANTONIO, TEXAS—
W&B Service Company LLP
An employee was repairing the suspension of a semi-trailer. He was installing an air bag to the suspension when his left ring finger was crushed between the air bag and the suspension mounting beam. The employee was hospitalized.
MEDLEY, FLORIDA—
Tri County Truck & Trailer Repair Inc
An employee was refueling a pressure washer when it ignited and exploded. He suffered multiple third-degree burns to his chest and hands.
VALLEY CITY, OHIO—
Fleet Mobile Maintenance
A mechanic had just finished a repair on a straight truck with a flatbed , which had been lifted using a bottle jack. As the employee was about to remove the jack, it failed. The truck shifted forward, dropped down, and struck the employee's chest. He suffered broken ribs and a broken shoulder.
MOBILE, ALABAMA—
U-J Chevrolet Co., Incorporated
An employee was performing diagnostic work on a vehicle engine. As the employee was leaning over the front of the vehicle, the engine was activated. A fuel leak had produced fumes around the engine, and the ignition spark ignited them. The employee suffered second-degree burns to both hands, both biceps, and the upper chest area.
FORT MYERS, FLORIDA—
Monro, Inc.
An employee was hot patching a tire, which involves lighting a flammable liquid on fire to patch the tire. The flammable liquid contacted his arm, and he sustained burns to his arms and face.
More severe injuries in SOUTH CAROLINA
NEWBERRY, SOUTH CAROLINA—
U.S. Postal Service
An employee delivered a package. On her way back to her vehicle she was attacked by two dogs that came from around a corner. She was hospitalized with dog bites.
JOHNS ISLAND, SOUTH CAROLINA—
AHTNA Marine & Construction
The injured employee was standing by the controls for the electric spud system on the barge, preparing to raise the spuds. Meanwhile, an excavator was moving a mat on the deck. As the excavator swung from port to starboard, it's counterweight struck the injured employee s shoulder, causing them to lose balance and fall against the spud controls. The employee sustained bruises and contusions to their right shoulder and chest.
NORTH CHARLESTON, SOUTH CAROLINA—
Fairbanks Morse, LLC
A technician was operating a crane hoist to lift/remove a cylinder head from the main engine (port). The load was lifted at an angle, causing the cylinder head to get stuck on the cylinder head studs. When it became free from the studs, the cylinder head swung. It struck the technician and caught them against the cabinet door. This resulted in an amputation of their left index fingertip at the distal knuckle.
CHARLESTON, SOUTH CAROLINA—
Container Maintenance Corporation
An employee was securing a power cord to a refrigerated truck container. A truck started backing up to connect with the container and the employee was pinned between the tires of the container and the bolster of the truck, resulting in a fractured leg.
COLUMBIA, SOUTH CAROLINA—
U.S. Postal Service
An employee was delivering a package to a house when a dog came through the storm door, jumped on the employee, and bit them in the lower jaw.